人工晶体学报, 2020, 49 (4): 576, 网络出版: 2020-06-15  

CdSe波片 6~12 μm波段增透膜研究

Study on 6-12 μm Anti-reflection Coating for CdSe Wave Plate
作者单位
1 西华师范大学物理与空间科学学院,南充 637002
2 中国科学院国家天文台,北京 100012
摘要
采用垂直无籽晶气相升华法生长出直径37 mm的优质硒化镉(CdSe)单晶体,并沿光轴方向切割出20 mm×20 mm×3 mm的CdSe波片初胚。经研磨和抛光,在2~20 μm波段CdSe波片的红外透过率约为70%。为进一步提高波片的透过率,采用Essential-Macleod软件辅助设计方案,选用YF3和ZnS为双层增透膜材料,并获得最佳的膜系厚度。镀膜后的CdSe波片在6~12 μm波段透过率达到90%,在10.5 μm处的透过率最高,峰值高达99%。
Abstract
High quality CdSe single crystal with diameter of 37 mm was grown by the modified vertical unseeded sublimation method, and the embryo of CdSe wave plate with size of 20 mm×20 mm×3 mm was cut along the optical axis. After grinding and polishing, the infrared transmittance test results show that the transmittance of the CdSe wave plate in the range of 6-12 μm was about 70%. In order to further increase the transmittance of the CdSe wave plate, the Essential-Macleod software-assisted design solution was adopted. YF3 and ZnS were selected as the two-layer anti-reflection coating materials, and the optimal film thickness was obtained. The coated CdSe wave plate had a transmittance of 90% in the 6-12 μm band, and the highest transmittance at 10.5 μm, with a peak of 99%.
参考文献

[1] 姜会林,付 强,段 锦,等. 红外偏振成像探测技术及应用研究[J].红外技术, 2014(5):5-9.

[2] 刘重阳, 赵万利. 红外偏振成像技术研究[J].光电技术应用, 2014, 29(5):31-33.

[3] 刘 忠, 邓元勇, 季海生,等. 中国地基大太阳望远镜[J].中国科学:物理学 力学 天文学, 2012(12):22-31.

[4] Taylor A. A study of novel mid-infrared optical devices:wave plates and tunable filters[D]. Illinois:University of Illinois at Urbana-Champaign, 2013.

[5] Zeng T, Zhao B, Zhu S, et al. Optimizing the growth procedures for CdSe crystal by thermal analysis techniques[J].Journal of Crystal Growth, 2011, 316(1):15-19.

[6] Pawlak M, Chirtoc M, Horny N, et al. Spectrally resolved modulated infrared radiometry of photothermal, photocarrier, and photoluminescence response of CdSe crystals:Determination of optical, thermal, and electronic transport parameters[J].Journal of Applied Physics, 2016, 119(12):125108.

[7] Dmitriev V G, Gurzadyan G G, Nikogosyan D N. Handbook of nonlinear optical crystals. (second, revised and updated edition)[J].Crystal Research & Technology,1997,32(5):636-636.

[8] Frese K W. A high efficiency single crystal cdse photoelectrochemical solar cell and an associated loss mechanism[J].Applied Physics Letters,1982,40(3):275-277.

[9] Herbst R L, Byer R L. Singly resonant cdse infrared parametric oscillator[J].Applied Physics Letters,1972,21(5):189-191.

[10] Zhu S F, Zhao B J. Modified growth of cadmium selenide single crystal from the vapor phase and quality characterization[J].Crystal Research and Technology,2000,35(11-12):1239-1244.

[11] Bhar G C, Ghosh G. Temperature dependent phase-matched nonlinear optical devices using CdSe and ZnGeP2[J].IEEE Journal of Quantum Electronics,1980,16(8):838-843.

[12] Vodopyanov K L. Megawatt peak power 8-13 μm CdSe optical parametric generator pumped at 2.8 μm[J].Optics Communications, 1998, 150(1-6):210-212.

[13] Zeng T X, Zhao B J, Zhu S F. Thermodynamic analysis of the sublimation process in cadmium selenide[J].Journal of Alloys and Compounds, 2010, 491(1-2):172.

[14] 曾体贤,赵北君,朱世富,等.红外非线性光学晶体CdSe生长与性能表征[J].人工晶体学报,2009,38(2):326-329.

[15] Zhu S F, Zhao B J, Jin Y, et al. Growth and characterization of CdSe single crystals by modified vertical vapor phase method[J].Journal of Crystal Growth, 2002, 240(3):454-458.

[16] 卢大洲,朱世富,赵北君,等.硒化镉晶体定向切割方法研究[J].人工晶体学报,2008,37(5):1121-1126.

[17] 魏顺勇,张志勇,杨 辉,等.酸性条件下的CdSe波片抛光工艺研究[J].人工晶体学报,2018,47(6):1280-1285.

[18] 孙可祥.红外增透膜的研究[D].西安:西安工业大学, 2013.

[19] 潘永强,朱 昌.硒化锌基底8~12μm高性能增透膜的研究[J].红外与激光工程, 2005(4):19-21+78.

[20] 李大琪,刘定权,张凤山.6.4~15μm宽带增透膜的设计与制作[J].红外与毫米波学报,2006(2):135-137.

[21] 于天燕,朱福荣,刘定权,等.硫化锌透镜中长波红外宽带增透膜的研制[J].光学学报,2005(2):270-273.

[22] Lemarquis F, Marchand G, Amra C. Design and manufacture of low-absorption ZnS YF3 antireflection coatings in the 3.5-16 μm spectral range[J].Applied Optics, 1998, 37(19):4239-4244.

[23] 广州机床研究所激光室.计算膜系特征矩阵的一种新方法[J].机床与液压, 1977(6):133-145.

杨明, 杨辉, 张志勇, 田文, 明仕文, 张敏, 曾体贤. CdSe波片 6~12 μm波段增透膜研究[J]. 人工晶体学报, 2020, 49(4): 576. YANG Ming, YANG Hui, ZHANG Zhiyong, TIAN Wen, MING Shiwen, ZHANG Min, ZENG Tixian. Study on 6-12 μm Anti-reflection Coating for CdSe Wave Plate[J]. Journal of Synthetic Crystals, 2020, 49(4): 576.

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!