红外与激光工程, 2016, 45 (12): 1221001, 网络出版: 2017-01-12  

金刚石衬底的氧化钒薄膜光电特性研究

Optical and electrical properties of vanadium pentoxide films deposited on diamond substrates
作者单位
南京航空航天大学 机电学院, 江苏 南京 210016
摘要
利用射频磁控溅射方法, 在光学级单晶金刚石上制备了氧化钒薄膜, 然后对其结构与厚度、表面形貌、电学及光学性能进行了表征。实验结果表明, 制备出的薄膜表面均匀性良好, 为单一组分的V2O5薄膜, 在(001)面有明显的择优取向, 薄膜结晶度和表面形貌非常好; 电学性能方面, 获得了三组不同厚度V2O5薄膜温阻特性曲线, 当薄膜为150 nm时, 薄膜的电学突变特性最好, 电阻值变化幅度将近3个数量级; 对不同厚度薄膜的光学响应特性进行了测试分析, 当受到高能激光照射时, 薄膜均出现了相变和回复, 薄膜的光学开关时间均随着膜厚的增加而增加, 其中光学关闭时间的变化范围为1.6~2.5 ms, 回复时间的变化范围为26~33 ms。
Abstract
Vanadium oxide films(V2O5) were deposited under 35 min by RF reactive magnetron sputtering at the substrates of single-crystal diamond. Its structure, thickness, surface morphology, electrical performances and optical performances were studied. The results indicated that the deposited film is polycrystalline V2O5 film on(001) preferred orientation, possessing great crystallization behavior and the surface topography. In term of electrical performance, the V2O5 films′ temperature-resistance characteristics were tested under three thicknesses, and the electrical mutation is best when the thickness is 150 nm. The optical-switching properties of the films were tested, and process of phase transition and recovery would occur when the films were irradiated by high-energy laser. The optical closing times range from 1.6 ms to 2.5 ms, and the response times vary from 26 ms to 33 ms, which indicate that the films′ response time increases with the increase of film thickness.
参考文献

[1] 张海林, 周林, 左文博, 等. 临近空间高超声速导弹红外特性研究[J]. 激光与红外, 2015(1): 41-44.

    Zhang Hailin, Zhou Lin, Zuo Wenbo, et al. Study on infrared radiation feature of near space hypersonic missle[J]. Laser and Infrared, 2015(1): 41-44. (in Chinese)

[2] 张洪文, 曹国华, 李延伟, 等. 临近空间超声速航空遥感器光学窗口热光学评价[J]. 红外与激光工程, 2014, 43(12): 3958-3962.

    Zhang Hongwen, Cao Guohua, Li Yanwei, et al. Thermal-optical evaluation to optical window of near space aerial remote sensor surrounding hyperson[J]. Infrared and Laser Engineering, 2014, 43(12): 3958-3962. (in Chinese)

[3] 黄晨, 梁小虎, 王建军, 等. 临近空间红外探测像面照度建模与仿真[J]. 红外与激光工程, 2014, 43(12): 3958-3962.

    Huang Chen, Liang Xiaohu, Wang Jianjun, et al. Modeling and simulation of imaging plane irradiance for near space infrared detecting[J]. Infrared and Laser Engineering, 2014, 43(12): 3958-3962. (in Chinese)

[4] Sullivan M, Son T V, Beaudoin N, et al. Optical scattering during phase transition of vanadium dioxide[J]. Optics Communications, 2015, 356: MQ1580.

[5] 张立超, 高劲松. 长春光机所深紫外光学薄膜技术研究进展[J]. 光学 精密工程, 2012, 20(11): 2395-2401.

    Zhang Lichao, Gao Jinsong. Developments of DUV coating technologies in CIOMP[J]. Optics and Precision Engineering, 2012, 20(11): 2395-2401. (in Chinese)

[6] Ingole R S, Lokhande B J. Effect of pyrolysis temperature on structural, morphological and electrochemical properties of vanadium oxide thin films[J]. Journal of Analytical & Applied Pyrolysis, 2016, 137(2): 1116-1121.

[7] Benmoussa M, Ibnouelghazi E, Bennouna A, et al. Electrochromism in sputtered V2O5 thin films: structural and optical studies[J]. Thin Solid Films, 2002, 405(1-2): 11-16.

[8] Zhang H F, Wu Z, Wu X, et al. Preparation and phase transition properties of nanostructured zirconium-doped vanadium oxide films by reactive magnetron sputtering[J]. Thin Solid Films, 2014, 568: 63-69.

[9] 左杨平, 卢文壮, 张圣斌, 等. 面向激光防护应用的金刚石/V2O5膜系设计与制备[J]. 红外与激光工程, 2014, 43(5): 1522-1526.

    Zuo Yangping, Lu Wenzhuang, Zhang Shengbin, et al. Design and fabrication of diamond/V2O5 films in continuous laser protection[J]. Infrared and Laser Engineering, 2014, 43(5): 1522-1526. (in Chinese)

[10] 刘成有, 宁丹, 张保平, 等. ZnO薄膜非线性光学特性的实验研究[J]. 光学 精密工程, 2005, 13(3): 265-271.

    Liu Chengyou, Ning Dan, Zhang B P, et al. Study on nonlinear-optical properties of ZnO thin films[J]. Optics and Precision Engineering, 2005, 2005, 13(3): 265-271. (in Chinese)

[11] Marcelo S B, Carlos L Ferreira, Roberto R, et al. Vanadium oxide thin films produced by magnetron sputtering from a V2O5 target at room temperature[J]. Infrared Physics & Technology, 2013, 60: 103-107.

[12] 田雪松. 用于抗激光致盲的氧化钒薄膜制备及光学相变特性研究[D]. 哈尔滨: 哈尔滨工业大学, 2008: 68-74.

    Tian Xuesong. Study on anti-laser-damage vanadium oxide thin films′s preparation and optical phase-transition character[D]. Harbin: Harbin Institute of Technology, 2008: 68-74. (in Chinese)

[13] 陈涛. 具有相变特性的氧化钒薄膜制备与光学特性研究[D]. 天津: 天津大学, 2011: 41-44.

    Chen Tao. Study on fabrication and optical property of VOx thin films with phase transition characteristic[D]. Tianjin: Tianjin University, 2011: 41-44. (in Chinese)

[14] 王尧, 吴志明, 罗振飞, 等. 溅射时间对氧化钒薄膜光学特性的影响[J]. 电子器件, 2011, 34(6): 629-632.

    Wang Yao, Wu Zhiming, Luo Zhenfei, et al. Effects of sputtering time on the optical properties of vanadium oxide thin films[J]. Chinese Journal of Electron Devices, 2011, 34(6): 629-632. (in Chinese)

[15] Wu Xiaochun, Lai Fachun, Lin Limei, et al. Influence of thermal cycling on structural, optical and electrical properties of vanadium oxide thin films[J]. Applied Surface Science, 2008, 255(8): 2840-2844.

[16] 唐晋发, 顾培夫, 刘旭, 等. 现代光学薄膜技术[M]. 杭州:浙江大学出版社, 2006: 274-276.

    Tang Jinfa, Gu Peifu, Liu Xu, et al. Modern Optical Thin Film Technology[M]. Hangzhou: Zhejiang University Press, 2006: 274-276. (in Chinese)

[17] Son T V, Zongo K, Ba C, et al. Pure optical phase control with vanadium dioxide thin films[J]. Optics Communications, 2014, 320(2): 151-155.

[18] 张圣斌, 左敦稳, 卢文壮, 等. 磁控溅射法制备的五氧化二钒薄膜光电特性[J]. 光学 精密工程, 2015, 23(9): 2438-2445.

    Zhang Shengbin, Zuo Dunwen, Lu Wenzhuang, et al. Optical and electrical properties of vanadium pentoxide films prepared by RF reactive magnetron sputtering[J]. Optics and Precision Engineering, 2015, 23(9): 2438-2445. (in Chinese)

[19] 张圣斌, 左敦稳, 卢文壮, 等. 基于不同衬底的五氧化二钒薄膜光电特性研究[J]. 光学学报, 2016, 36(4): 0431001.

    Zhang Shengbin, Zuo Dunwen, Lu Wenzhuang, et al. Optical and electrical properties of vanadium pentoxide films deposited on different substrates[J]. Acta Optica Sinica, 2016, 36(4): 0431001. (in Chinese)

[20] Ho Y K, Chang C C, Wei D H, et al. Characterization of gasochromic vanadium oxides films by X-ray absorption spectroscopy[J]. Thin Solid Films, 2013, 2013(10): 461-465.

[21] Zhang Yinyuan, Zheng Rongshan, Liu Jinsong. Analysis of pulsed laser disturbance and damage on satellite-borne detector[J]. Journal of Electronics & Information Technology, 2006, 28(9): 1758.

[22] Wang Siwen, Li Yan, Guo Lihong. Analysis on the disturbance of CO2 laser to long-wave infrared HgCdTe detector[J]. Journal of Infrared and Millimeter Waves, 2010, 29(2): 102.

[23] Xu Lijun, Cai Hongxing, Li Changli. Responsivity of photoelectric detector irradiated by intense laser[J]. Journal of Applied Optics, 2010, 31(6): 1018.

张圣斌, 左敦稳, 卢文壮. 金刚石衬底的氧化钒薄膜光电特性研究[J]. 红外与激光工程, 2016, 45(12): 1221001. Zhang Shengbin, Zuo Dunwen, Lu Wenzhuang. Optical and electrical properties of vanadium pentoxide films deposited on diamond substrates[J]. Infrared and Laser Engineering, 2016, 45(12): 1221001.

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!