半球形整流罩厚度对气动热辐射的影响

王惠; 党凡阳; 张荣达; 明月; 范志刚

doi:doi:10.3788/irla201847.1204002

红外与激光工程, 2018, 47 (12): 1204002, 网络出版: 2019-01-10

半球形整流罩厚度对气动热辐射的影响

Influence of thickness of hemispherical dome on aerodynamic thermal radiation

论文大纲

王惠党凡阳张荣达明月范志刚

作者单位

哈尔滨工业大学空间光学工程研究中心, 黑龙江哈尔滨 150001

气动热辐射半球形整流罩厚度 aerodynamic thermal radiation hemispherical dome thickness

摘要

气动加热的高温整流罩会产生强烈的红外辐射, 影响导引头对目标的探测精度。为了寻求减弱整流罩气动热辐射的方法, 建立了气动热辐射数学模型。利用有限元软件以及建立的气动热辐射数学模型对不同厚度的半球形整流罩气动热和气动热辐射进行了数值仿真, 得到了半球形整流罩厚度对气动热和气动热辐射的影响规律。研究结果表明, 在相同飞行工况下, 工作10 s时, 当半球形整流罩厚度由3 mm增厚到8 mm, 整流罩驻点温度降低了16.23%; 形变量减少了54.2%; 探测器接收面上的最大辐照度减少了84.43%。因此增加整流罩的厚度可以降低整流罩的温度, 有效减小整流罩的热形变和探测器上接收到的干扰辐射照度。

Abstract

Aerodynamically heated high temperature dome will produce strong infrared radiation. In some serious cases when the probe reaches saturation, the detecting precision of the seeker for target can be severely affected. In order to reduce the aerodynamic thermal radiation of the dome, a mathematical model of aerodynamic thermal radiation was developed. The aerodynamic heat and the aerodynamic thermal radiation of the hemispherical dome with different thickness were simulated numerically by software of finite element analysis and the mathematical model of aerodynamic thermal radiation. The influence of the thickness of hemispherical dome on the aerodynamic thermal response and aerodynamic heat radiation was analyzed and obtained. Research indicates that in the same flight conditions and in 10 s, when the thickness of hemispherical dome increases from 3 mm to 8 mm, the stagnation point temperature of the dome reduces by 16.41%; the thermal deformation of the dome reduces by 54.2%; the maximum irradiance of receiving surface of the detector decreases by 84.43%. Therefore increasing the thickness of the dome can not only reduce the temperature of the dome, but also effectively reduce the thermal deformation of the dome and the interference radiation illumination received on the detector.

参考文献

[1] 孙赤全, 赵侃, 孟军合. 滚仰式导引头红外光学系统设计[J]. 红外与激光工程, 2017, 46(2): 0204005.

Sun Chiquan, Zhao Kan, Meng Junhe. IR optial system design of roll-elevation seeker[J]. Infrared and Laser Engineering,2017, 46(2): 0204005. (in Chinese)

[2] 赵瑞, 荣吉利, 李跃军. 整流罩母线形状对脉动压力环境的影响研究[J]. 兵工学报, 2017, 38(5): 1020-1026.

Zhao Rui, Rong Jili, Li Yuejun. Rocket fairing with different curvetypes[J]. Acta Armamentarii, 2017, 38(5): 1020-1026.

[3] 殷兴良. 气动光学原理[M]. 北京: 中国宇航出版社, 2003.

Yin Xingliang. Principle of Aero-optics[M]. Beijing: China Aerospace Press, 2003. (in Chinese)

[4] 范志刚, 肖浩苏, 高豫强. 气动热环境下高速飞行器光学头罩特性分析[J]. 应用光学, 2009, 30(3): 361-365.

Fan Zhigang, Xiao Haosu, Gao Yuqiang. Characteristics analysis of high-speedaerocraft optical dome in aerodynamic heating enviroment[J]. Journal of Applied Optics, 2009, 30 (3): 361-365. (in Chinese)

[5] Hao Chenglong, Chen Shouqian, Fan Zhigang. Comprehensive analysis of imaging quality degradation of airborne optical system for aerodynamic flow field around the optical window [J]. Applied Optics, 2013, 52(33): 7889-7898.

[6] 郝成龙. 二次曲面光学头罩及外流场气动光传输研究[D].哈尔滨: 哈尔滨工业大学, 2014.

Hao Chenglong. Optical transmisson of quadric surface optical window and aero dynamic flow field[D]. Harbin: Harbin Institute of Technology, 2014. (in Chinese)

[7] 张荣实. 红外窗口/整流罩技术新进展[J]. 红外与激光工程, 2007, 36(S2): 114-119.

Zhang Rongshi. Recent advances in infrared window and dome technologies[J]. Infrared and Laser Engineering, 2007, 36(S2): 114-119. (in Chinese)

[8] 薛文慧. 气动热环境下共形整流罩热辐射特性研究[D]. 哈尔滨: 哈尔滨工业大学, 2016.

Xue Wenhui. Research on the thermal radiation characteristics of conformal come in the aero-dynamic environment[D]. Harbin: Harbin Institute of Technology, 2016. (in Chinese)

[9] 魏群, 艾兴乔, 姜湖海, 等. 超音速光学导引头整流罩的形状优化[J]. 光学精密工程, 2010, 18(2): 384-389.

Wei Qun, Ai Xingqiao, Jiang Huhai, et al. Optimizing design of dome figure for supersonic seekers[J]. Optics and Precision Engineering, 2010, 18(2): 384-389. (in Chinese)

[10] 孟立新, 赵丁选, 张立中, 等. 机载激光通信中气动光学的影响及补偿[J]. 光学精密工程, 2014, 22(12): 3231-3238.

Meng Lixin, Zhao Dingxuan, Zhang Lizhong, et al. Boundary layer effect and compensation in airborne laser communication[J]. Optics and Precision Engineering, 2014, 22(12): 3231-3238. (in Chinese)

[11] 张鑫, 杜智远, 乔彦峰, 等. 全捷联激光半主动导引头线性视场研究[J]. 中国光学, 2015, 8(3): 415-421.

Zhang Xin, Du Zhiyuan, Qiao Yanfeng, et al. Study on linear field of strapdown semi-active laser seeker[J]. Chinese Optics, 2015, 8(3): 415-421. (in Chinese)

[12] 王亚辉, 王强, 张伯川, 等. 红外窗口气动热辐射效应评估方法[J]. 红外与激光工程, 2016, 45(2): 0204001.

Wang Yahui, Wang Qiang, Zhang Bochuan, et al. Evaluation method for aero-thermo-radiation effect of IR window[J].Infrared and Laser Engineering, 2016, 45(2): 0204001. (in Chinese)

[13] Han Wei, Zhuo Yuejin, Hu Xinqi. Study on aero-optical effect of a hypersonic missile infrared image guide[C]//SPIE, 2009, 7513(75): 73516.

[14] Visknata R, Anderson E E. Heat transfer smitransparent solids[J]. Advances in Heat Trasfer, 1975, 11: 317-441.

[15] 张云, 王淑岩, 孙益善, 等. 超音速状态下整流罩红外窗口的选型问题研究[J]. 红外技术, 1999, 21(2): 11-14.

Zhang Yun, Wang Shuyan, Sun Yishan, et al. Determination of the dome infrared windowin the supersonic mode[J]. Infrared Technology, 1999, 21(2): 11-14. (in Chinese)

王惠, 党凡阳, 张荣达, 明月, 范志刚. 半球形整流罩厚度对气动热辐射的影响[J]. 红外与激光工程, 2018, 47(12): 1204002. Wang Hui, Dang Fanyang, Zhang Rongda, Ming Yue, Fan Zhigang. Influence of thickness of hemispherical dome on aerodynamic thermal radiation[J]. Infrared and Laser Engineering, 2018, 47(12): 1204002.

半球形整流罩厚度对气动热辐射的影响

关于本站 Cookie 的使用提示

全站搜索

半球形整流罩厚度对气动热辐射的影响

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索