红外与激光工程, 2015, 44 (7): 2097, 网络出版: 2016-01-26  

大型射电望远镜结构总体方案研究

Research on large radio telescope structure scheme
作者单位
1 长安大学 建筑工程学院,陕西 西安 710061
2 哈尔滨工业大学 土木工程学院,黑龙江 哈尔滨 150090
摘要
针对我国待建的110 m全可动射电望远镜(QTT)的工作特点,以提高主反射面精度为目标,以最佳吻合抛物面为拟合标准,分析了传统结构方案致使精度较低的本质原因为反射体变形不均匀,主要源于如下三方面:主反射面存在集中荷载作用、背架结构支承方案不合理、背架结构体系空间受力性能不佳。基于此,改变副反射面撑腿坐落位置,对背架结构采用三角锥、四角锥相结合的网架式结构方案,并对其引入一种高度极对称的伞撑式支承方案。最终提出的全可动望远镜结构总体方案显著提高了主反射面精度,其RMS最大值可降至0.306 mm;相较目前世界最大的全可动射电望远镜GBT而言,其反射面积增大了10%,精度提高了12.6%,自重降低了40%,其研究成果达到国际先进水平。
Abstract
Aiming at the 110 m fully-steerable radio telescope(which is called QTT for short ) to be built in the future, in order to improve the main reflector precision, the traditional structural concepts were analyzed based on the best fit paraboloid. It is the uneven deformation of the reflector that results in the lower precision. It is mainly due to the following three aspects: the concentrated loads exist on the main reflecting surface, the back frame supporting system is unreasonable and the back frame structure has a poor performance. Based on this, the catching points of the secondary reflector supporting legs were changed, the space truss structure combining cones and quadrangular pyramids were adopted as the back frame structure design, and a kind of polar symmetry umbrella structure was proposed as the supporting system for the back frame structure. Finally the introduced scheme for the fully-steerable radio telescope significantly improved the main reflector precision, its maximal RMS was reduced to 0.306 mm. Compared with the fully-steerable radio telescope GBT which has the largest diameter in the world, the reflective surface area of QTT increases 10%, the surface precision improves 12.6% and the total weight decreases 40%. The QTT performance reaches the international advanced level.
参考文献

[1] Qiu Y H. A novel design for giant radio telescopes with an active spherical main reflector[J]. Chinese Journal of Astronomy and Astrophysics, 1998, 22(3): 361-368.

[2] Leve R, Melosh R. Computer design of antenna reflectors[J]. Journal of Structural Engineering, 1973, 99(11): 2011-2030.

[3] Von Hoerner. Homologous deformations of tiltable telescope[J]. Journal of Structural Engineering, 1967, 93(5): 1305-1325.

[4] Zhang Yalin. The static and dynamic analysis of the 50 m-diameter radio telescope antenna structure[J]. Electro-Mechanical Engineering, 2004, 20(6): 37-40. (in Chinese)

[5] Zhang Yalin, Liu Weiming. Dynamic design of 50 m-diameter radio telescope antenna pedestal structure[J]. Radio Communications Techniques, 2003(5): 5-6. (in Chinese)

[6] Zhang Zhanguo. Control system design and experimental software for the large radio telescope fine tuning platform[D]. Xi′an: Xi′an Electronic Sience & Technology University, 2008: 21-30. (in Chinese)

[7] Qian Hongliang, Liu Yan, Fan Feng. The analysis on solar radiation of Shanghai 65 m radio telescope[J]. Engineering Mechanics, 2012, 29(10): 379-380. (in Chinese)

[8] Ye Shanghui. The Antenna Structure Design[M]. Beijing: National Defence Industrial Press, 1980. (in Chinese)

[9] Duan Baoyan. Analysis and Measurement of Antenna Structure Optimization[M]. Xi′an: Xi′an Electronic Sience &Technology University Press, 2006. (in Chinese)

[10] Wang Jian. The Principle and Design of Antenna[M]. Beijing: National Defence Industrial Press, 1993. (in Chinese)

[11] Christianson W N. Radio Telescope[M]. Beijing: China Science Press, 1977. (in Chinese)

[12] Liu Yan. Structural selection and accuracy control of the large aperture all-movable telescope[D]. Harbin: Harbin Institute of Technology, 2013: 20-21. (in Chinese)

[13] Cheng Jingquan. The Principle and Design of Astronomical Telescope[M]. Beijing: China Science and Technology Press, 2003. (in Chinese)

[14] Pang Yi. Key technologies of large antenna mechanical design[J]. Electro-Mechanical Engineering, 2011, 27(3): 28-30. (in Chinese)

[15] Ma Pingzhong. Design and research of the large telescope[J]. Applied Optics, 1994(03): 6-11. (in Chinese)

[16] Li Jianfeng. Heat transfer analysis and design of large photovoltaic array telescope structure[D]. Nanjing: Nanjing University of Science and Technology, 2007. (in Chinese)

[17] Qiu Yuhai. Large spherical radio telescope with the active reflector[J]. Astrophysical Journal, 1998, 18(2): 107-113. (in Chinese)

[18] Yang Shijie. Several problems in the manufacture of modern telescopes[J]. Acta Astronomica Sinica, 1962(2): 203-207. (in Chinese)

刘岩, 钱宏亮, 范峰. 大型射电望远镜结构总体方案研究[J]. 红外与激光工程, 2015, 44(7): 2097. Liu Yan, Qian Hongliang, Fan Feng. Research on large radio telescope structure scheme[J]. Infrared and Laser Engineering, 2015, 44(7): 2097.

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!