红外与激光工程, 2019, 48 (7): 0717001, 网络出版: 2019-08-07  

利用波长调制光谱的燃烧场温度原位测量

In-situ temperature measurement for combustion field based on wavelength modulation spectroscopy
作者单位
天津中德应用技术大学 智能制造学院, 天津 300350
摘要
针对高炉煤气成分复杂、燃烧效率低、燃烧稳定性差的问题, 提出了基于波长调制光谱(Wavelength Modulation Spectroscopy, WMS)的高炉煤气燃烧场温度测量方法。WMS具有抗噪声能力强、测量精度高和灵敏度好的特点, 适用于高炉煤气燃烧场的温度测量。基于可调谐二极管激光吸收光谱技术的测量特点, 以H2O为目标气体, 选取波长位于1 391.67 nm和1 397.75 nm的吸收谱线, 通过两个激光器时分复用的方式获取两条目标吸收谱线, 对黑体炉和平面火焰燃烧炉进行温度测量, 达到了实验验证的目的。实验结果表明, 所提检测方案对高炉煤气所在500~2 000 K温度范围内都有较高的测量灵敏度, 检测结果线性度优于99%。现场实验验证系统可满足高炉煤气的温度场测量等原位在线测量的应用, 为后续的燃烧优化和节能减排奠定了基础。
Abstract
Aiming at the problems of composition complexity, low combustion efficiency and poor combustion stability of blast furnace gas, a temperature measurement method of blast furnace gas combustion field based on wavelength modulation spectroscopy(WMS) was proposed. WMS method has the characteristics of strong anti-noise ability, high measurement accuracy and high sensitivity. It was suitable for temperature measurement of blast furnace gas combustion field. Based on the measurement characteristics of tunable diode laser absorption spectroscopy, H2O was taken as the target gas, and its absorption spectral lines at 1 391.67 nm and 1 397.75 nm were selected. Two target absorption lines spectra were obtained by time division multiplexing of two lasers. The temperature measurement of blackbody furnace and flat flame combustion furnace were measured respectively for the experimental verification. The results show that the proposed detection scheme has high sensitivity to the temperature range of 500-2 000 K, and the linearity of the detection results is better than 99%. The field test verified that the system can meet the application of in-situ on-line measurement of blast furnace gas temperature, which lays a foundation for subsequent combustion optimization and energy saving and emission reduction.
参考文献

[1] Zhang Bo, Chen Hongbo. Study on sustainable development of China′s iron and steel industry CDM project [D]. Beijing: Institute of Urban Development and Environment, Chinese Academy of Social Sciences; Chinese Academy of Social Sciences; Center for Urban Development and Environment, Chinese Academy of Social Sciences, 2009. (in Chinese)

[2] Wang Feng, Tang Yuxuan. Recognition of types of blast furnace gas pipelines based on fuzzy control[J]. Journal of Hebei United University Natural Science Edition, 2018, 40(1): 98-103. (in Chinese)

[3] Sun Hao, Zhou Dayong, Zhang Hongchao, et al. Simulation of single-junction GaAs photovoltaic cell output characteristics by continuous wave laser irradiation[J]. Infrared and Laser Engineering, 2017, 46(10): 1003006. (in Chinese)

[4] Wei Jifeng, Hu Xiaoyang, Zhang Kai, et al. Technologies and development trends of directly measuring high energy laser energy[J]. Infrared and Laser Engineering, 2017, 46(7): 0706004. (in Chinese)

[5] Cui Haibin, Wang Fei, Li Meiyi. Measurements of CO2 temperature and concentration in high temperature environment based on tunable diode laser absorption spectroscopy[J]. Laser & Optoelectronics Progress, 2018, 55(5): 420-426. (in Chinese)

[6] Nie Wei, Kan Ruifeng, Xu Zhenyu, et al. Measuring spectral parameters of water vapor at low temperature based on tunable diode laser absorption spectroscopy[J]. Acta Physica Sinica, 2017, 66(20): 204204. (in Chinese)

[7] Qu Dongsheng, Hong Yanji, Wang Guangyu, et al. Wavelength-modulation spectroscopy for measurements of gas pressure, temperature and H2O concentration in high-temperature environment[J]. Spectroscopy and Spectral Analysis, 2017, 37(5): 1339-1344. (in Chinese)

[8] Jia Haoyue, Liu Shuping, Wei Jilin. The application of boltzmann distribution in gas temperature measurement by spectral method[J]. Journal of Taiyuan University of Science and Technology, 2017, 38(6): 71-74. (in Chinese)

[9] Xiong Yongquan, Zhou Bin, Wang Yihong, et al. Calibration-free one-line method based on wavelength modulation spectroscopy[J]. Acta Optica Sinica, 2017, 37(9): 0930002. (in Chinese)

[10] Qu Dongsheng, Hong Yanji, Wang Guangyu, et al. Study on mass flux measurement methods of gas based on scanningwavelength modulation spectroscopy[J]. Chinese Journal of Lasers, 2016, 43(9): 0904006. (in Chinese)

[11] Zhang Liang. On the methodology of measuring high-speed flows using tunable diode laser absorption spectroscopy[J]. Acta Physica Sinica, 2012, 61(3): 355-367. (in Chinese)

[12] Lins B, Zinn P, Engelbrecht R, et al. Simulation-based comparison of noise effects in wavelength modulation spectroscopy and direct absorption TDLAS[J]. Applied Physics B, 2010, 100(2): 367-376.

[13] Qu Dongsheng, Hong Yanji, Wang Guangyu, et al. Measurement of multi-parameters of gas based on the wavelength modulation spectroscopy[J]. Journal of Infrared and Millimeter Waves, 2016, 35(4): 470-476. (in Chinese)

[14] Shao Xin, Wang Feng, Zhang Xinghui, et al. CO gas system of quasi-continuous laser modulation absorption spectroscopy[J]. Infrared and Laser Engineering, 2017, 46(5): 0506006.(in Chinese)

[15] Zhou Xin, Liu Xiang, Jeffries J B, et al. Development of a sensor for temperature and water concentration in combustion gases using a single tunable diode laser[J]. Measurement Science and Technology, 2003, 14(8): 1459-1468.

[16] Rothman L S, Gordon I E, Barber R J, et al. HITEMP, the high-temperature molecular spectroscopic database[J]. Journal of Quantitative Spectroscopy and Radiative Transfer, 2010, 111(15): 2139-2150.

[17] Li Jinyi, Du Zhenhui. Temperature sensing using direct absorption spectroscopy combined with time division multiplexing[J]. Laser Journal, 2015, 36(8): 58-62. (in Chinese)

[18] Sun Qi, Wang Guangyu, Qu Dongsheng. Measurement of gas temperature based on H2O absorption spectroscopy in wavelength range of 1 397 nm[J]. Development & Innovation of Machinery & Electrical Products, 2017, 30(2): 80-83. (in Chinese)

邵欣. 利用波长调制光谱的燃烧场温度原位测量[J]. 红外与激光工程, 2019, 48(7): 0717001. Shao Xin. In-situ temperature measurement for combustion field based on wavelength modulation spectroscopy[J]. Infrared and Laser Engineering, 2019, 48(7): 0717001.

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!