脉冲激光沉积法制备的PZT铁电薄膜的残余应力

邓水凤; 杨建桃; 郑学军

中国激光, 2005, 32 (12): 1693, 网络出版: 2006-06-01

脉冲激光沉积法制备的PZT铁电薄膜的残余应力

Residual Stress in Pb(Zr0.52Ti0.48)O3 Ferroelectric Thin Films Prepared by Pulsed Laser Deposition

论文大纲

邓水凤 ^1,*杨建桃 ¹郑学军 ^1,2

作者单位

¹ 湘潭大学材料与光电物理学院,湖南湘潭 411105

² 湘潭大学先进材料及其波变特性教育部重点实验室,湖南湘潭 411105

薄膜残余应力脉冲激光沉积统计平均 X射线衍射 thin films residual stress pulsed laser deposition statistic average X-ray diffraction

摘要

根据压电本构方程和细观力学统计平均法,采用X射线衍射(XRD)测量Pb(Zr0.52Ti0.48)O3(PZT)铁电薄膜的残余应力。考虑激光沉积生长过程中,薄膜相变应力、热应力和本征应力对自由能的贡献,分析薄膜晶胞在晶体坐标系上的应力应变状态。由坐标转换将晶胞残余应力从晶体坐标系转换到样品坐标系得到任意取向晶粒的残余应力,通过取向平均得到薄膜样品坐标系上的残余应力。用脉冲激光沉积法(PLD)制备了不同厚度的PZT薄膜。利用X射线衍射分别采用细观力学统计平均法和传统sin2ψ法测量了PZT薄膜的残余应力。结果表明,两种结果在数值上是比较接近的(绝对差范围0.3～16.6 MPa),残余压应力随着膜厚的增加从96 MPa左右减少到45 MPa左右。最后讨论了细观力学统计平均法的优缺点。

Abstract

Based on piezoelectric constitutive equations and statistic average of micro-mechanics, residual stresses in Pb(Zr0.52Ti0.48)O3 (PZT) ferroelectric thin films were measured by X-ray diffraction (XRD). Theoretically, it is considered that the intrinsic stress, thermal stress and transformation stress contribute to the minimum energy principium. The stress-strain relationship of the uint cell in the crystallite coordinate is studied. Residual stresses in any oriented crystallites are obtained via the transformation matrix from the crystallite coordinate to the sample coordinate, and residual stresses in thin films are statistically averaged by orientations. Experimentally, residual stresses in PZT thin films prepared by pulsed laser deposition (PLD) were evaluated by the statistic average of micro-mechanics and conventional sin2ψ method. The results evaluated by two models are very close, with absolute errors ranging from 0.3 MPa to 16.6 MPa. The residual stresses of PZT thin films are compressive and decrease from about 96 MPa to 45 MPa with the increase of the thickness. The measured results and advantages of the statistic average model of micro-mechanics are discussed.

参考文献

[1] Yan Zhi, Zheng Xuejun, Zhou Yichun. Chang of PZT thin films ferroelectric properties induced by laser beam thermal shock [J]. Chinese J. Lasers, 2004, 31(2):210～214
言智,郑学军,周益春. 激光热冲击引起PZT压电薄膜铁电性能的变化[J]. 中国激光, 2004, 31(2):210～214

[2] Luo Hao, Zheng Xuejun, Zhou Yichun. Preparation of ferroelectric PZT thin films by pulsed laser deposition and the dependence of substrate temperature [J]. Chinese J. Lasers, 2001, A28(6):570～572
罗皓,郑学军,周益春. 脉冲激光沉积法制备PZT铁电薄膜及衬底温度对膜的影响[J]. 中国激光, 2001, A28(6):570～572

[3] Zhu Yunming, Zhang Renjie, Dou Jianqing et al.. Residual stress analysis for Ni-base thermal sprayed coatings with laser melting and consolidation [J]. Chinese J. Lasers, 1993, A20(7):530～535
朱允明,张人佶,窦建清等. 激光熔凝镍基热喷涂层残余应力的X射线衍射分析[J]. 中国激光, 1993, A20(7):530～535

[4] . C. Zhou, Z. Y. Yang, X. J. Zheng. Residual stress in PZT thin films prepared by pulsed laser deposition[J]. Surface and Coatings Technology, 2003, 162: 202-211.

[5] . Determination of residual stresses in Pb(Zr0.53Ti0.47)O3 thin films with Raman spectroscopy[J]. Appl. Phys. Lett., 2001, 79(25): 4112-4114.

[6] B. M. Clemens, J. A. Bain. Stress determination in textured thin films using X-ray diffraction [J]. Mat. Res. Soc. Bull., 1992, ⅩⅦ:46～51

[7] . Noheda, D. E. Cox, G. Shirane et al.. A monoclinic ferroelectric phase in the Pb(Zr1-xTix)O3 solid solution[J]. Appl. Phys. Lett., 1999, 74(14): 2059-2061.

[8] . X-ray diffraction measurement of residual stress in PZT thin films prepared by pulsed laser deposition[J]. Acta. Mater., 2004, 52(11): 3313-3322.

[9] S. Y. Kweon, S. H. Yi, S. K. Choi. Intrinsic stress dependence of c-axis orientation ratio in PbTiO3 thin films deposited by reactive sputtering [J]. J. Vac. Sci. Tech., 1997, A15(1):57～61

[10] . M. Foster, Z. Li, M. Buckett et al.. Substrate effects on the structure of epitaxial PbTiO3 thin films prepared on MgO, LaAlO3, and SrTiO3 by metalorganic chemical-vapor deposition[J]. J. Appl. Phys., 1995, 78(4): 2607-2622.

[11] . . Dependence of electrical properties on film thickness in Pb(ZrxTi1-x)O3 thin films produced by metalorganic chemical vapor deposition[J]. J. Appl. Phys., 1993, 73(11): 7857-7863.

[12] Ma Qingfang, Fang Rongsheng, Xiang Licheng et al.. Practical Handbook of Thermal Physics Properties [M]. First ed.. Beijing: China Publishing House of Agriculture Mechanism, 1986. 42～96
马庆芳,方荣生,项立成等. 实用热物理性质手册[M]. 第一版. 北京:中国农业机械出版社, 1986. 42～96

[13] E. Heifets, R. E. Cohen. Ab initio study of elastic properties of Pb(Ti,Zr)O3 [R]. Washington, DC(USA): AIP Conference Proceedings, 2002, 626(1):150～159

[14] . Description of crystallite orientation in polycrystalline materials Ⅲ. General solution to pole figure inversion[J]. J. Appl. Phys., 1965, 36(6): 2024-2031.

邓水凤, 杨建桃, 郑学军. 脉冲激光沉积法制备的PZT铁电薄膜的残余应力[J]. 中国激光, 2005, 32(12): 1693. 邓水凤, 杨建桃, 郑学军. Residual Stress in Pb(Zr0.52Ti0.48)O3 Ferroelectric Thin Films Prepared by Pulsed Laser Deposition[J]. Chinese Journal of Lasers, 2005, 32(12): 1693.

脉冲激光沉积法制备的PZT铁电薄膜的残余应力

关于本站 Cookie 的使用提示

全站搜索

脉冲激光沉积法制备的PZT铁电薄膜的残余应力

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索