光学学报, 2011, 31 (8): 0814002, 网络出版: 2011-07-21   

激光作用下环氧/硅树脂复合涂层的1.3 μm反射特性研究

Reflectance of Epoxy/Organsilicone Composite Coating at 1.3 μm under Laser Irradiation
作者单位
1 国防科学技术大学光电科学与工程学院, 湖南 长沙 410073
2 西北核技术研究所激光与物质相互作用国家重点实验室, 陕西 西安 710024
3 清华大学工程物理系, 北京 100084
摘要
利用共轭反射计装置,开展了真空环境中激光作用下环氧/硅树脂双层结构复合涂层的1.3 μm反射特性研究,测量得到了涂层反射率随样品背表面温度的变化曲线。通过有限元分析和界面热阻修正得到了反射率随涂层温度的变化关系,探讨了反射率随温度的变化机理。研究结果表明,红外连续激光损伤环氧/硅树脂复合涂层,主要表现为底漆热解引发的鼓包分层和面漆热解导致的烧蚀变色;常温下涂层对1.3 μm激光的反射率约为0.80,激光辐照初始时变化不明显,鼓包前后出现波动,测量区涂层鼓包、烧蚀后反射率显著下降,最终保持在一个相对较低值;反射率变化与涂层热解过程、损伤方式密切相关,涂层对1.3 μm激光的反射率变化存在3个特征温度,分别对应底漆热解、面漆热解和表面状态趋于稳定时的温度。
Abstract
Experimental research on 1.3 μm reflectance of epoxy/organsilicone two-layer composite coating under infrared continuous-wave (CW) laser irradiation in vacuum is carried out. An experimental system for laser irradiation and reflectance measurement is set up with conjugated reflectometer. Results of signal detection theory (SDT) analysis indicate that heat deposition generated by laser makes pyrogenation of epoxy primer which leads to form and burst of bubbles and thermal ablation of topcoat. Heat transfer within coating-metal structure is simulated by finite element analysis procedure with interface thermal resistance modification, and the temperature-dependent reflectance is presented. Investigation results show that the change of reflectance is related to the modes of damage and processes of decomposition. 1.3 μm reflectance of epoxy/organsilicone coating is about 0.80 at room temperature, changes slightly at the very beginning of laser irradiation, decreases remarkably while bubbles burst and thermal ablation occurrs, and finally maintains a rather low level. There are three characteristic temperatures of reflectance evolution, the decomposition temperature of epoxy primer, the decomposition temperature of organosilicone topcoat, and the decomposition temperature when the reaction ends and the surface tends to be steady.
参考文献

[1] D. Bergstrom, A. Kaplan, J. Powell et al.. Laser absorptance measurements in opaque solids [C]. Proc. of 10th Nordic Laser Materials Processing Conference, 2005, 91~115

[2] D. Bergstrom, J. Powell, A. Kaplan. The absorptance of steels to NdYLF and NdYAG laser light at room temperature [J]. Applied Surface Science, 2007, 253(11): 5017~5028

[3] D. Bergstrom, J. Powell, A. Kaplan. The absorptance of non-ferrous alloys to NdYAG and NdYLF laser light at room temperature [J]. Appl. Opt., 2007, 48(8): 1290~1301

[4] 焦路光, 赵国民. 1.319 μm处45#钢反射率随温度变化的实验研究[J]. 应用光学, 2009, 30(6): 983~987

    Jiao Luguang, Zhao Guomin. Temperature dependence of reflectivity of 45# steel at the wavelength of 1.319 μm [J]. J. Appl. Opt., 2009, 30(6): 983~987

[5] 张永强, 王贵兵. 大气环境中不同温度30CrMnSiA钢吸收率的点测量[J]. 激光技术, 2010, 34(4): 517~519

    Zhang Yongqiang, Wang Guibing. Point measurement of absorptivity of 30CrMnSiA steel at different temperature in atmosphere[J]. Laser Technology, 2010, 34(4): 517~519

[6] 张永强, 王贵兵, 唐小松 等. 两种纤维增强复合材料连续激光烧蚀阈值测量及吸收特性分析[J]. 强激光与粒子束, 2009, 21(2): 199~202

    Zhang Yongqiang, Wang Guibing, Tang Xiaosong et al.. Ablation threshold measurement and absorption characteristic analysis of two fiber reinforced composites irradiated by CW laser [J]. High Power Laser and Particle Beams, 2009, 21(2): 199~202

[7] John T. Neu. Measurement of hemispherical directional reflectance in the infrared [C]. SPIE, 1993, 1995: 101~120

[8] R. K. Freeman, F. A. Rigby, S. E. Doerr et al.. Reflectance of laser damaged spacecraft thermal control materials [C]. SPIE, 1998, 3343: 983~994

[9] R. K. Freeman, F. A. Rigby. Temperature-dependent reflectance of plated metals and composite materials under laser irradiation [J]. J. Thermophysics and Heat Transfer, 2000, 14(3): 305~312

[10] L. S. Andrew, F. S. Donald, E. C. Russel et al.. Temperature effects on reflectance and emittance measurements of martin black and enhanced martin blacks surfaces [C]. SPIE, 1996, 2864: 387~405

[11] Z. Zhang, M. F. Modest. Temperature-dependent absorptance of ceramics for NdYAG and CO2 laser processing applications [J]. ASME J. Heat Transfer, 1998, 120(2): 322~327

[12] 黄延禄, 杨福华, 梁工英 等. 用原位法测定铝合金对激光的吸收率[J]. 中国激光, 2003, 30(5): 449~453

    Huang Yanlu, Yang Fuhua, Liang Gongying et al.. Using in-situ technique to determine laser absorptivity of Al-alloys[J]. Chinese J. Lasers, 2003, 30(5): 449~453

[13] 崔春阳, 吴炜, 虞钢 等. 球墨铸铁材料对激光的吸收率[J]. 中国激光, 2006, 33(7): 977~980

    Cui Chunyang, Wu Wei, Yu Gang et al.. On laser absorptivity of ductile iron [J]. Chinese J. Lasers, 2006, 33(7): 977~980

[14] 吴丽雄, 叶锡生, 刘泽金. 聚氨酯黑漆的红外激光损伤机理研究[J]. 中国激光, 2011, 38(3): 0302002

    Wu Lixiong, Ye Xisheng, Liu Zejin. Investigation of infrared CW laser damage mechanism on polyurethane-based black paint [J]. Chinese J. Lasers, 2011, 38(3): 0302002

[15] 邹捷书, 朱群志, 李永光 等. 一种建筑节能涂料反射特性的实验研究[J]. 光学学报, 2010, 30(2): 480~484

    Zou Jieshu, Zhu Qunzhi, Li Yongguang et al.. Experimental study of the reflectance for architectural energy saving coatings [J]. Acta Opitca Sinica, 2010, 30(2): 480~484

[16] 吴丽雄, 王立君, 林新伟 等. 用于材料反射率测量的共轭反射计设计与分析[J]. 光学 精密工程, 2010, 18(12): 2521~2529

    Wu Lixiong, Wang Lijun, Lin Xinwei et al.. Design and analysis of conjugated reflectometer for reflectance measurement [J]. Optics and Precision Engineering, 2010, 18(12): 2521~2529

[17] J. B. Henderson, J. A. Wiebelt, M. R. Tant. A model for the thermal response of polymer composite materials with experimental verification [J]. J. Composite Materials, 1985, 19(6): 579~595

[18] 闵桂荣, 郭舜. 航天器热控制[M]. 北京: 科学出版社, 1998. 95~96, 476~516

    Min Guirong, Guo Shun. Spacecraft Thermal Control [M]. Beijing: Science Press, 1998. 95~96, 476~516

[19] 姚允斌, 解涛, 高英敏. 物理化学手册[M]. 上海: 上海科学技术出版社, 1985. 716~718

    Yao Yunbin, Xie Tao, Gao Yingmin. Handbook of Physical Chemistry [M]. Shanghai: Shanghai Scientific and Technical Publishers, 1985. 716~718

吴丽雄, 叶锡生, 王立君, 吴耀军, 刘卫平, 刘泽金. 激光作用下环氧/硅树脂复合涂层的1.3 μm反射特性研究[J]. 光学学报, 2011, 31(8): 0814002. Wu Lixiong, Ye Xisheng, Wang Lijun, Wu Yaojun, Liu Weiping, Liu Zejin. Reflectance of Epoxy/Organsilicone Composite Coating at 1.3 μm under Laser Irradiation[J]. Acta Optica Sinica, 2011, 31(8): 0814002.

本文已被 5 篇论文引用
被引统计数据来源于中国光学期刊网
引用该论文: TXT   |   EndNote

相关论文

加载中...

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!