基于扫描波长调制光谱的气体质量流量测量方法研究

基于扫描波长调制光谱方法实现了超声速气流的温度、H2O组分浓度、压强、速度以及质量流量的测量。利用两条H2O吸收谱线的谐波信号，研究了均匀流场中超声速气流多参数同时测量的方法。基于波长调制光谱技术的测量结果能准确反映均匀流场中的气体参数，然而实际流场往往具有边界层。针对具有边界层的近似均匀流场，数值仿真研究了谱线选择和边界层厚度对流场中心流测量结果的影响。仿真结果表明，随着边界层厚度不断增大，测量结果误差逐渐增大，选择对边界层温度不灵敏的吸收谱线能够有效降低边界层的影响。对超燃直连台隔离段内的超声速气流进行实验研究，结果表明基于波长调制光谱的测量方法在强噪声和强振动的环境中具有较高的测量精度。温度、H2O组分浓度、压强、速度以及质量流量测量值与预测值的最大相对偏差分别在8.2%、7.2%、2.0%、3.1%和6.4%以内。

Abstract

The temperature, H2O concentration, pressure, velocity and mass flux of supersonic gas flow are measured based on scanning wavelength-modulation spectroscopy method. The simultaneous measurement methods of multiple parameters of supersonic gas flow in uniform flow filed are studied using the harmonic signals of two H2O absorption spectral lines. The measurement results based on wavelength modulation spectrum technology can precisely reflect the gas parameters in the uniform flow field, while the actual flow field often has the boundary layers. Aiming at the approximate uniform flow field with boundary layer, the numerical simulation is carried out to study the effect of line selection and boundary layer thickness on the measurement result of core flow in flow field. The simulation results show that the measurement error increases with the boundary layer thickness, and the absorption spectral lines which are insensitive to temperature of boundary layers can effectively decrease the influence of boundary layer. The experiments of supersonic gas flow is carried out in a direct-connected scramjet test facility isolator, the results show that the measurement method based on wavelength modulation spectroscopy has high measurement accuracy in strong noise and strong vibration environments. The maximum relative deviation of predicted value and measured value for temperature, H2O concentration, pressure, velocity and mass flux are less than 8.2%, 7.2%, 2.0%, 3.1% and 6.4%, respectively.

参考文献

[1] Bolshov M A, Kuritsyn, Y A, Romanovskii Y V. Tunable diode laser spectroscopy as a technique for combustion diagnostics[J]. Spectrochimica Acta Part B: Atomic Spectroscopy, 2015, 106: 45-66.

[2] Philippe L C, Hanson R K. Laser diode wavelength-modulation spectroscopy for simultaneous measurement of temperature, pressure, and velocity in shock-heated oxygen flows[J]. Applied Optics, 1993, 32(30): 6090-6103.

[3] Miller M F, Kessler W J, Allen M G, et al. Diode laser-based air mass flux sensor for subsonic aeropropulsion inlets[J]. Applied Optics, 1996, 35(24): 4905-4912.

[4] Upsichulte B L, Miller M F, Allen M G, et al. Continuous water vapor mass flux and temperature measurements in a model scramjet combustor using a diode laser sensor[C]. Reno: 37th AIAA Aerospace Sciences Meeting & Exhibit, 1999, AIAA 99-0518.

[5] Lyle K H, Jeffries J B, Hanson R K. Aeroengine mass flux sensor based on laser absorption measurements of oxygen velocity and density[C]. Tucson: 41st AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit, 2005, AIAA-2005-3784.

[6] Chang L S, Jeffries J B, Hanson R K. Mass flux sensing via tunable diode laser absorption of water vapor[J]. AIAA Journal, 2010, 48(11): 2687-2693.

[7] Chang L S, Strand C L, Jeffries J B, et al. Supersonic mass-flux measurements via tunable diode laser absorption and nonuniform flow modeling[J]. AIAA Journal, 2011, 49(12): 2783-2791.

[8] 杨斌, 何国强, 刘佩进, 等. 利用TDLAS技术开展吸气式发动机来流热试实验参数测量[J]. 中国激光, 2011, 38(5): 0508006.

Yang Bin, He Guoqiang, Liu Peijin, et al. TDLAS-based measurements of parameters for incoming flow hot-firing test of air breathing rocket engine[J]. Chinese J Lasers, 2011, 38(5): 0508006.

[9] 宋俊玲, 洪延姬, 王广宇, 等. 基于激光吸收光谱技术的超声速气流参数测量[J]. 红外与激光工程, 2014, 43(11): 3510-3515.

Song Junling, Hong Yanji, Wang Guangyu, et al. Measurement of supersonic flow parameters using laser absorption spectroscopy[J]. Infrared and Laser Engineering, 2014, 43(11): 3510-3515.

[10] 谷俊青, 徐胜利. 可调谐二极管激光吸收光谱技术测量风洞流速[J]. 激光与红外, 2014, 44(1): 8-11.

Gu Junqing, Xu Shengli. Fluid velocity measurement of supersonic wind tunnel with tunable diode laser absorption spectroscopy[J]. Laser＆Infrared, 2014, 44(1): 8-11.

[11] Gamache B R, Kennedy S, Hawkins R, et al. Total internal partition sums for molecules in the terrestrial atmosphere[J]. Journal Molecular Structure, 2000, 517-518: 407-425.

[12] Rothman L S, Gordon I E, Babikov Y, et al. The HITRAN 2012 molecular spectroscopic database[J]. Journal of Quantitative Spectroscopy and Radiative Transfer, 2013, 130: 4-50.

[13] Goldenstein C S, Hanson R K. Diode-laser measurements of linestrength and temperature-dependent lineshape parameters for H2O transitions near 1.4 μm using Voigt, Rautian, Galatry, and speed-dependent Voigt profiles[J]. Journal of Quantitative Spectroscopy and Radiative Transfer, 2015, 152: 127-139.

[14] Liu X, Jeffries J B, Hanson R K, et al. Development of a tunable diode laser sensor for measurements of gas turbine exhaust temperature[J]. Applied Physics B, 2006, 82(3): 469-478.

屈东胜, 洪延姬, 王广宇, 王明东, 潘虎. 基于扫描波长调制光谱的气体质量流量测量方法研究[J]. 中国激光, 2016, 43(9): 0904006. Qu Dongsheng, Hong Yanji, Wang Guangyu, Wang Mingdong, Pan Hu. Study on Mass Flux Measurement Methods of Gas Based on Scanning Wavelength Modulation Spectroscopy[J]. Chinese Journal of Lasers, 2016, 43(9): 0904006.

基于扫描波长调制光谱的气体质量流量测量方法研究

关于本站 Cookie 的使用提示

全站搜索

基于扫描波长调制光谱的气体质量流量测量方法研究

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索