基于光斑跟踪系统的位敏传感器误差修正

位置敏感探测器(PSD)测量误差主要来自于自身非线性、干扰和安装倾斜的影响, 且PSD的直接测量范围受限于探测器的尺寸。针对这些问题, 分析了自身非线性、干扰和安装倾斜的影响原理, 根据测量值与实际值的线性关系, 提出利用伺服模组与PSD相结合的光斑跟踪系统来进行局部拟合实时校准的方法减小干扰影响并消除PSD安装倾斜误差, 利用线性度较好的中间区域减小自身非线性影响。实验以Al2O3/PEN为样品, 利用研制的光斑跟踪系统对上述方法进行的验证结果显示, 线性相关系数维持在1±0.001 5/40 mm之间, 线性度标准误差减小到0.3 μm/40 mm以下, 最大误差在16 μm/40 mm之内且测量范围也可增大到模组的行程200 mm, 此方法简单有效、灵活实用, 特别适用于光强度弱且多变和测试范围较大的场合。

Abstract

The accuracy of position sensitive detector(PSD) is mainly affected by the non-linearity, interference and the installation tilt error, and the measurable range is limited by the size of the detector. Based on the analysis of the influencing mechanism of the non-linearity, the interference and the installation tilt error, a speckle tracking system was introduced to remove the influence by local fitting and real-time calibration according to the linear relationship between the actual value and the measured value. Al2O3/PEN sample was used to experimentally verify the designed spot tracking system platform. The results show that the linear correlation coefficient maintains in a range of 1±0.001 5, the linearity standard error is reduced to 0.3 μm/40 mm, the maximum error is less than 16 μm/40 mm and the measurable range can be increased to the stroke of the module, 200 mm in this work. This method is effective, flexible and practical for position detection applications especially under feeble light condition and for large measuring range.

参考文献

[1] Sch 觟ssler S, Bromberger B, Brandis M, et al. Time and position sensitive single photon detector for scintillator read-out[J]. Journal of Instrumentation, 2012, 7(2): C02048.

[2] Urbain X, Bech D, Van Roy J P, et al. A zero dead-time multi-particle time and position sensitive detector based on correlation between brightness and amplitude[J]. Review of Scientific Instruments, 2015, 86(2): 023305.

[3] 程继伟, 巩马理, 贾维溥, 等. 基于PSD 的二维定心激光扫描器摆角测量系统[J]. 红外与激光工程, 2003, 32(1): 57-60.

Cheng Jiwei, Gong Mali, Jia Weipu, et al. Deflection angle measurement system using PSD for a 2 DOF laser scanner[J]. Infrared and Laser Engineering, 2003, 32(1): 57-60. (in Chinese)

[4] 张敏, 梁雁冰. 二维四边形位置敏感探测器实验研究[J]. 红外与激光工程, 2013, 42(2): 459-464.

Zhang Ming, Liang Yanbin. Experiment on two dimensional quadrilateral position sensing detector[J]. Infrared and Laser Engineering, 2013, 42(2): 459-464. (in Chinese)

[5] Cui S, Soh Y C. Linearity indices and linearity improvement of 2-d tetralateral position-sensitive detector[J]. Electron Devices, IEEE Transactions on, 2010, 57(9): 2310-2316.

[6] Guanghui W, Shum P, Guoliang X, et al. Position detection improvement of position sensitive detector(psd) by using analog and digital signal processing[C]//Information, Communications & Signal Processing, 2007 6th International Conference on. IEEE, 2007: 1-4.

[7] 王广志, 丁海曙. 位置敏感器件(PSD)的杂光干扰研究[J]. 清华大学学报: 自然科学版, 1997, 37(1): 61-64.

Wang Guangzhi, Ding Haishu. Light disturbance to position sensitive detectors-pattern and methods to overcome it[J]. Journal of Tsinghua University(Science and Technology), 1997, 37(1): 61-64. (in Chinese)

[8] 段洁, 孙向阳, 蔡敬海, 等. PSD 在激光位移检测系统中的应用研究[J]. 红外与激光工程, 2007, 36(S): 281-284.

Duan Jie, Zhang Xiangyan, Cai Jinghai, et al. Applications research to PSD in the laser displacement detecting system[J]. Infrared and Laser Engineering, 2007, 36(S): 281-284.(in Chinese)

[9] 田垅, 刘宗田. 最小二乘法分段直线拟合[J]. 计算机科学, 2012, 39(B06): 482-484.

Tian Long, Liu Zongtian. Least-squares Method Piecewise Linear Fitting[J]. Computer Science, 2012, 39(B06): 482-484. (in Chinese)

[10] 宋殿友. 精密 PSD 微位移在线测量技术的研究与应用[D]. 天津: 天津大学, 2012.

Song Dianyou. Research and application on technology of precise PSD micro-displacement online measurement[D]. Tianjin: Tianjin University, 2012. (in Chinese)

[11] 曾宪阳, 张志良. PSD 激光三角法弱反射微振动测量系统[J]. 浙江师范大学学报(自然科学版), 2009, 32(3): 298-302.

Zeng Xianyang, Zhang Zhiliang. A system measuring m icro vibration in weak reflection based on PSD and laser triangulation method[J]. Journal of Zhejiang Normal University(Natural Sciences), 2009, 32(3): 298-302. (in Chinese)

[12] Chung I J, Kang I B. Flexible display technology-opportunity and challenges to new business application[J]. Molecular Crystals and Liquid Crystals, 2009, 507(1): 1-17.

帅红俊, 张帅, 宋建涛, 张建华. 基于光斑跟踪系统的位敏传感器误差修正[J]. 红外与激光工程, 2016, 45(4): 0417002. Shuai Hongjun, Zhang Shuai, Song Jiantao, Zhang Jianhua. Error corrections for position sensitive detector based on speckle tracking system[J]. Infrared and Laser Engineering, 2016, 45(4): 0417002.

基于光斑跟踪系统的位敏传感器误差修正

关于本站 Cookie 的使用提示

全站搜索

基于光斑跟踪系统的位敏传感器误差修正

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索