强激光与粒子束, 2013, 25 (11): 2909, 网络出版: 2013-11-14  

大气微波等离子体射流处理H2S废气

Treatment of waste H2S by atmospheric pressure microwave plasma jet
作者单位
1 武汉工程大学 材料科学与工程学院, 等离子体化学与新材料重点实验室, 武汉 430073
2 中国石油大学 化学工程学院, 北京 102249
摘要
利用大气微波等离子体射流(MPJ)技术对H2S气体进行了处理研究。考察了温度、微波功率、载气(Ar)流量及气源总流量对H2S分解效率的影响。实验结果表明,为了有利于H2S的处理,必须将温度控制在一定范围之内;随着微波功率和载气流量的增加,H2S分解率均是先增加后减小;随着气源总流量的增加,H2S分解率逐渐降低。当H2S与Ar气体流量比达到10∶90,总流量为1000 mL/min,微波功率为1000 W时,H2S的分解率达到最佳值91.32%。对处理后得到的固体物质进行拉曼(Raman)光谱和X射线衍射(XRD)分析,结果表明回收得到的固体物质为纯度极高的硫。
Abstract
The treatment of H2S gas by the atmospheric pressure microwave plasma jet (MPJ) technology was studied. The influences of the temperature, the microwave power, the carrier(Ar) flow and total gas flow rate on H2S decomposition were investigated. The results show that, the temperature must be controlled in a certain range in order to process hydrogen sulfide; as the microwave power and the carrier gas flow increases, the decomposition rate of H2S first increases, then decreases; with the increase of the total gas flow rate, the decomposition rate of H2S falls. The maximum decomposition rate of H2S reaches to 91.32%, when the mass ratio of H2S to Ar is 10∶90, the total flow is 1000 mL/min, and the microwave power is 1000 W. The production of the treatment was characterized by Raman spectroscopy and XRD (X-ray diffraction), and the results show the solid state material is high purity sulfur.
参考文献

[1] 刘克杰, 阳洪, 应建康. 吸收氧化法处理硫化氢废气[J].气体净化, 2006, 6(1): 20-22.(Liu Kejie, Yang Hong, Ying Jiankang. Treatment of waste H2S by oxidation absorption method. Gas Purification, 2006, 6(1):20-22)

[2] 段晓堂. 液碱吸收法处理硫化氢废气[J].安徽化工, 1998, 96(6): 29-30.(Duan Xiaotang. Treatment of waste H2S by caustic soda liquid absorption method. Anhui Chemical Industry, 1998, 96(6): 29-30)

[3] 龚斌, 董放战, 何静华,等. 树脂吸附法处理硫化氢气体的研究[J].铝镁通讯,2005(4):37-38.(Gong Bin, Dong Fangzhan, He Jinghua, et al. Study on treatment of H2S by resin adsorption method. Aluminum Magnesium Communication, 2005(4): 37-38)

[4] 黄焱歆, 郭静, 杨秀云,等. 生物膜法控制硫化氢污染的试验研究[J].城市环境与城市生态,1996, 9(1):15-19.(Huang Yanxin, Guo Jing, Yang Xiouyun,et al. An experimental study on control of hydrogen sulfide by biological film method. Urban Environment & Urban Ecology, 1996, 9(1):15-19)

[5] 董永治, 王涵慧, 俞稼镛. 微波等离子体方法分解H2S制氢[J]. 太阳能学报, 1997, 18(2): 142-145.(Dong Yongzhi, Wang Haihui, Yu Jiayong. Hydrogen production by H2S microwave plasma dissociation. Acta Energiae Solaris Sinica, 1997, 18(2): 142-145)

[6] Bagautdinov A Z. Plasma chemical production of hydrogen from H2S containing gases in microwave-discharge[C]//International Hydrogen Conference. 1992.

[7] Gutsol K, Nunnally T, Rabinovich A, et al. Plasma assisted dissociation of hydrogen sulfide[J]. International Journal of Hydrogen Energy, 2012,37(2):1335-1347.

[8] Reddy E L, Biju V M, Subrahmanyam C. Production of hydrogen and sulfur from hydrogen sulfide assisted by nonthermal plasma[J]. Applied Energy, 2012,95(7):87-92.

[9] Reddy E L, Biju V M, Subrahmanyam C. Production of hydrogen from hydrogen sulfide assisted by dielectric barrier discharge[J]. International Journal of Hydrogen Energy, 2012,37(3):2204-2209.

[10] 马文, 王新强, 倪炳华. 微波催化法分解硫化氢的研究[J]. 石油与天然气化工, 1997,26(1):37-38.(Ma Wen, Wang Xinqiang, Ni Binghua. Study on dissociation of H2S by microwave catalysis method. Chemical Engineering of Oil & Gas, 1997, 26(1): 37-38)

[11] 刘繁, 汪建华, 王秋良,等. 常压微波等离子体炬装置的模拟与设计[J]. 强激光与粒子束, 2011, 23(6): 1504-1508.(Liu Fan, Wang Jianhua, Wang Qiuliang, et al. Numerical modeling and design of atmosphric pressure microwave plasma jet. High Power Laser and Particle Beams, 2011, 23(6): 1504-1508)

[12] 刘长林, 汪建华, 熊礼威,等. 大气微波等离子体炬装置设计及实验研究[J]. 低温物理学报, 2011, 33(3): 112-115.(Liu Changlin, Wang Jianhua, Xiong Liwei, et al. Design and experiment of an atmosphere microwave plasma torch device. Chinese Journal of Low Temperature Physics, 2011, 33(3): 112-115)

[13] 何凤姣, 刘红玲, 柴雅琴,等. 无机化学[M]. 北京: 科学出版社, 2001: 114.(He Fengjiao, Liu Hongling, Chai Yaqin, et al. Inorganic chemistry. Beijing: Science Press, 2001:114)

徐尧, 汪建华, 高建保, 薛垂庆. 大气微波等离子体射流处理H2S废气[J]. 强激光与粒子束, 2013, 25(11): 2909. Xu Yao, Wang Jianhua, Gao Jianbao, Xue Chuiqing. Treatment of waste H2S by atmospheric pressure microwave plasma jet[J]. High Power Laser and Particle Beams, 2013, 25(11): 2909.

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!