反射式倒装对1 300 nm激光器性能改善的分析

对AlGaInAs多量子阱1 300 nm FP激光器进行反射式倒装封装，在热沉上靠近激光器出光端面约10~20 μm的区域采用Au反射层，对器件垂直方向出光进行反射。测试结果显示，与常规封装相比，采用这种结构封装芯片垂直发散角从34.5°降低至17°，器件单模光纤的平均耦合功率从1 850 μW提高至2 326 μW，耦合效率从21.1%提高到26.5%。对两种激光器进行光电参数的测量，结果表明：与常规封装器件相比，采用反射式倒装结构器件的饱和电流从135 mA提高至155 mA，饱和输出功率从37 mW提高至42 mW，热阻从194 K/W降低至131 K/W。最后对两种器件在95 ℃环境温度、100 mA电流下进行加速老化实验，老化结果显示：在老化条件下，器件衰退系数从常规封装的4.22×10-5降低至1.06×10-5，寿命从5 283 h提高至21 027 h。

Abstract

AlGaInAs MQWs 1 300 nm FP lasers were packaged p-side down with a reflective submount which had 10-20 μm Au film near the facets of laser bare die. Compared to convention package form laser (LD-B), the divergence angle at FWHM of flip chip (LD-A) with a Au reflector decreases from 34.5° to 17° , and the average SMF coupling power increases from 1 850 μW to 2 326 μW, as the coupling efficiency increases from 21.1% to 26.5%. Compared to LD-B, the saturated current of LD-A increases from 135 mA to 155 mA, the saturated output power increasses from 37 mW to 42 mW, and the thermal resistance decreases from 194 K/W to 131 K/W. Finnaly, the aging experiments are carried out under the condition of 95 ℃ ambient temperature and 100 mA injection current. Compared to LD-B, the degradation coefficient of LD-A under aging condition decreases from 4.22×10-5 to 1.06×10-5, and the lifetime increases from 5 283 h to 21 027 h.

参考文献

[1] HUANG J S, NGUYEN T, HSIN W, et al.. Reliability of etched-mesa buried-heterostructure semiconductor lasers ［J］. IEEE Trans. Dev. Mater. Relib., 2005, 5(4):665-674.

[2] HUANG J S, MIAO R S, LU H, et al.. Theoretical and experimental thermal analysis of inp ridge lasers on submounts and TO packages ［J］. IEEE Trans. Dev. Mater. Relib., 2007, 7(2):363-368.

[3] HUANG J S, OLSON T, ISIP E. Human-body-model electrostatic-discharge and electrical-overstress studies of buried-heterostructure semiconductor lasers ［J］. IEEE Trans. Dev. Mater. Relib., 2007, 7(3):453-461.

[4] HUANG J S, LU H. Size effect on ESD Threshold and degradation behavior of InP buried heterostructure semiconductor lasers ［J］. Open Appl. Phys. J., 2009, 2:5-10.

[5] 王淑娜，张普，熊玲玲，等. 温度对高功率半导体激光器阵列“smile”的影响［J］. 光子学报, 2016, 45(5):7-12.

WANG S N, ZHANG P, XIONG L L, et al.. Influence of temperature on “smile” in high power diode laser bars ［J］. Acta Photon. Sinica, 2016, 45(5):7-12. (in Chinese)

[6] 金伟，李光慧，陈熙，等. 一体化半导体激光器的ANSYS热仿真及结构设计［J］. 光学精密工程, 2016, 24(5):1080-1086.

JIN W, LI G H, CHEN X, et al.. Structural design and ANSYS thermal simulation for semiconductor laser system ［J］. Opt. Precision Eng., 2016, 24(5):1080-1086. (in Chinese)

[7] KNAUER A, ERBERT G, STASKE R, et al.. High-power 808 nm lasers with a super-large optical cavity ［J］. Semicond. Sci. Technol., 2005, 20:621-624.

[8] BUGGE F, ZEIMER U, WENZEl H, et al.. Laser diodes with highly strained InGaAs MQWs and very narrow vertical far fields ［J］. Phys. Stat. Sol.(c), 2006, 3(3):423-426.

[9] CRUMP P, PIETRZAK A, BUGGE F, et al.. 975 nm high power diode lasers with high efficiency and narrow vertical far field enabled by low index quantum barriers ［J］. Appl. Phys. Lett., 2010, 96:131011-1-3.

[10] ABDULRAHMAN A M, ABDULLAH A, ABDELMAJID S. Waveguide design optimization for long wavelength semiconductor lasers with low threshold current and small beam divergence ［J］. J. Modern Phys., 2011, 2:225-230.

[11] 高树理. 半导体激光器和光纤的耦合［J］. 煤炭技术, 2010, 29(2):28-30.

GAO S L. Coupling of semiconductor laser with fiber ［J］. Coal Technol., 2010, 29(2):28-30.

[12] GUO X, SCHUBERT E F. Current crowding and optical saturation effects in GaInN/GaN light-emitting diodes grown on insulating substrates ［J］. Appl. Phys. Lett., 2001, 78:3337-3339.

[13] PEARTON S J, ABERNATHY C R, PANISH M B, et al..Implant induced high resistivity regions in InP and In GaAs［J］. J. Appl. Phys, 1989, 66(2):656-662.

[14] FAN Z F, MOHAMMAD S N, KIM W, et al.. Very low resistance multilayer Ohmic contact to n-GaN ［J］. Appl. Phys. Lett., 1996, 68(12):1672-1674.

[15] 张晓磊，薄报学，张哲铭，等. C-mount封装激光器热特性分析与热沉结构优化研究［J］. 发光学报, 2017, 38(7):891-896.

ZHANG X L, BO B X, ZHANG Z M, et al.. Thermal characteristics analysis of C-mount sink package laser and optimization of heat sink structure ［J］. Chin. J. Lumin., 2017, 38(7):891-896. (in Chinese)

[16] 施敏, 伍国珏. 半导体器件物理［M］. 西安：西安交通大学出版社, 2008.

SHI M, WU G J. Semicondudor Devices Physics ［M］. Xian: Xian Jiao Tong University Press, 2008. (in Chinese)

[17] MELANIE O, SWALES A. Capabilites and reliability of LEDs and laser diodes ［J］. Whats New in Electron., 2000, 20(6):1-5.

薛正群, 王凌华, 苏辉. 反射式倒装对1 300 nm激光器性能改善的分析[J]. 发光学报, 2018, 39(4): 534. XUE Zheng-qun, WANG Ling-hua, SU Hui. Analysis The Performance Improvement of 1 300 nm Laser with Reflective Flip Chip Package[J]. Chinese Journal of Luminescence, 2018, 39(4): 534.

反射式倒装对1 300 nm激光器性能改善的分析

关于本站 Cookie 的使用提示

全站搜索

反射式倒装对1 300 nm激光器性能改善的分析

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索