静电对GaN基高压LED特性的影响

韩禹; 郭伟玲; 樊星; 俞鑫; 白俊雪

doi:doi:10.3788/gzxb20144308.0823003

光子学报, 2014, 43 (8): 0823003, 网络出版: 2014-09-01

静电对GaN基高压LED特性的影响

Effects of Electrostatic-Discharge on GaN-Based High Voltage Light-Emitting Diode

论文大纲

韩禹 ^*郭伟玲樊星俞鑫白俊雪

作者单位

北京工业大学光电子技术省部共建教育部重点实验室, 北京 100124

高压LED 静电放电失效机理光电特性 GaN GaN High-voltage LED Electrostatic discharge Degradation mechanism Optical and electrical characteristics

摘要

对GaN基绿光高压LED分别施加-500、-1 000、-2 000、-3 000、-4 000、-5 000和-6 000 V的反向人体模式静电打击, 每次静电打击后, 测量样品的I-V特性曲线及光通量等参量, 研究静电打击对GaN基高压LED器件性能的影响.结果表明: 当样品经过-500, -1 000、-2 000、-3 000和-4 000 V的静电打击后, 由于LED器件内部产生了缺陷, 发生了软击穿并且反向漏电流明显增加, 但光通量的变化不明显；当经过-5 000 V和-6 000 V的静电打击后, 由于发生了热模式击穿, 温度迅速升高, 在结区形成熔融通道, 使LED的光通量明显减小, 甚至衰减到未打击时的一半；在经受-6 000 V的静电打击后, 正向电压的减小和反向漏电流的增加更加明显, 漏电现象更加明显, 严重影响了器件的性能, 最终使LED样品失效.

Abstract

GaN-based high-voltage green light-emitting diodes were biased by negative Human-Body-Mode electrostatic discharge (ESD) with -500,-1 000,-2 000,-3 000,-4 000,-5 000 and -6 000 V.The I-V characteristic and luminous flux under different electrostatic shock voltages were comparative analyzed after each shock.The results show that the LED has a soft breakdown which accompanied with apparent increased reverse leakage current and unapparent luminous flux change ,which due to the generation of defect after ESD stressing at -500,-1 000,-2 000,-3 000 and -4 000V;When the device was biased to -5 000 V and -6 000 V,a sharp decrease of luminous flux appears,even decay to 50% of light output than before stressing.And forward voltage and reverse leakage current show a large degree of decrease and increase respectively after ESD shock of -6000V,which is due to the thermal model breakdown at this moment.The thermal model breakdown make temperature rise rapidly and form a melting channel,which disabled the LED eventually.

参考文献

[1] JUNTUNEN E,SITOMANIEMI A,TAPANINEN O,et al.Thermal performance comparison of thick-film insulated aluminum substrates with metal core PCBs for high-power LED modules［J］.IEEE,2012,2(12):1957-1964.

[2] 罗晓霞,刘华,卢振武,等.实现LED准直照明的优化设计［J］.光子学报,2011,40(9):1351-1355.

LUO Xiao-xia,LIU Hua,LU Zhen-wu,et al.Automated optimization of free-form surface lens for LED collimation［J］.Acta Photonica Sinica,2011,40(9):1351-1355.

[3] 李伟,岳庆炀,孔繁敏,等.顶端ZnO纳米结构对GaN基LED 光提取效率的影响［J］.光子学报,2013,42(4):409-416.

LI Wei,YUE Qing-yang,KONG Fan-min,et al.Influence of surface ZnO nano-structures on the light emitting efficiency of GaN-based LED［J］.Acta Photonica Sinica,2013,42(4):409-416.

[4] CHEN K J,Kuo H T,Chiang Y C,et al.Efficiency and droop improvement in hybrid warm white LEDs using InGaN and AlGaInP high-voltage LEDs［J］.IEEE,2013,9(4):280-284.

[5] 曹东兴, 郭志友, 梁伏波,等.GaN基高压直流发光二极管制备及其性能分析［J］.物理学报,2012,61(13):511-517.

CAO Dong-xing,GUO Zhi-you,LIANG Fu-bo,et al.The fabrication and performance analysis of GaN-based HV LED［J］.Chinese Journal of Physics,2012,61(13):511-517.

[6] 李建华,崔元顺,陈贵宾.GaN结构相变、电子结构和光学性质［J］.光子学报,2013,42(2):161-166.

LI Jian-hua, CUI Yuan-shun, CHEN Gui-bin.Structural phase transition, electronic structures and optical properties of GaN［J］.Acta Photonica Sinica,2013,42(2):161-166.

[7] JEON S K,LEE J G,PARK E H,et al.The effect of the internal capacitance of InGaN-light emitting diode on the electrostatic discharge properties［J］.Applied Physics Letters,2009,94(13):131106.

[8] MENEGHINI M,VACCARI S,TRIVELLIN N,et al.Analysis of defect-related localized emission processes in InGaN/GaN-based LEDs［J］.IEEE,2012,59(5):1416-1422.

[9] ZHANG J H,WU B Q,SHIH T M,et al.Thermal analyses of alternating current light-emitting diodes［J］.Applied Physics Letters,2013,103:153505.

[10] 刘恩科, 朱秉升, 罗晋生.半导体物理学［M］.北京:电子工业出版社,2003:54.

[11] CAO X A,SANDVIK P M,LEBOEUF S F,et al.Defect generation in InGaN/GaN light-emitting diodes under forward and reverse electrical stresses［J］.Microelectronics Reliability,2003,43(12):1987-1991.

[12] 吴国庆,郭伟玲,朱彦旭等.人体模式静电对GaN基蓝光LED 载流子运动及其可靠性的影响［J］.发光学报,2012,33(10):1132-1137.

WU Guo-qing,GUO Wei-ling,ZHU Yan-xu,et al.Effects of human body mode electrostatic on carrier movement and the reliability of GaN-based blue light-emitting diode［J］.Chinese Journal of Luminescence,2012,33(10):1132-1137.

[13] MENEGHINI M,TAZZOLI A,RANZATO E,et al.A study of the failure of GaN-based LEDs submitted to reverse-bias stress and ESD events ［C］.Reliability Physics Symposium (IRPS),2010 IEEE International.IEEE,2010:522-527.

[14] 高光渤,李学信.半导体器件可靠性物理［M］.北京:科学出版社,1987.458-465.

[15] ARMSTRONG A,HENRY T A,KOLESKE D D,et al.Dependence of radiative efficiency and deep level defect incorporation on threading dislocation density for InGaN/GaN light emitting diodes ［J］.Applied Physics Letters,2012,101(16):162102-162102-4.

韩禹, 郭伟玲, 樊星, 俞鑫, 白俊雪. 静电对GaN基高压LED特性的影响[J]. 光子学报, 2014, 43(8): 0823003. HAN Yu, GUO Wei-ling, FAN Xing, YU Xin, BAI Jun-xue. Effects of Electrostatic-Discharge on GaN-Based High Voltage Light-Emitting Diode[J]. ACTA PHOTONICA SINICA, 2014, 43(8): 0823003.

静电对GaN基高压LED特性的影响

关于本站 Cookie 的使用提示

全站搜索

静电对GaN基高压LED特性的影响

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索