中国激光, 2013, 40 (11): 1103010, 网络出版: 2013-10-24   

激光参数对C/SiC复合材料烧蚀热的影响

Effect of Laser Parameters on C/SiC Composites Material Ablation Heat
作者单位
西北核技术研究所激光与物质相互作用国家重点实验室, 陕西 西安 710024
摘要
复合材料的抗激光烧蚀性能一般用烧蚀单位质量所需的激光能量(即烧蚀热)表征,这种表征方式忽略了激光强度与稳定性的影响。以C/SiC复合材料为例,在材料表面热化学平衡分析的基础上,基于复合材料激光烧蚀效应数值模拟程序,计算了不同参数下激光辐照复合材料的烧蚀热,分析了强度、频率、占空比等激光参数对烧蚀效率的影响。研究结果表明,烧蚀热与占空比、激光强度有关,与重复频率关系不大。激光强度越大,烧蚀热越小;占空比减小,单位烧蚀质量所需的能量增大,即烧蚀热随占空比的减小而增大;在平均功率密度及占空比相同的前提下,不同重复频率对加热影响很小。对C/SiC复合材料的激光烧蚀,相同平均功率密度下,激光强度不稳定性越大,烧蚀热的期望值越小。
Abstract
The ablation resistance of composite material is usually characterized by ablation heat that laser energy is consumed per unit ablation mass. Whereas the characterization ignores the effects of laser parameters. Taking C/SiC composite material as an example, by using a program for the numerical simulation of laser ablation of composite material, the ablation heat of C/SiC composite material is computed for different laser parameters. Effects of intensity, repetitive frequency and duty radio are analyzed. The result indicates that ablation heat is mainly correlated with intensity and duty cycle of the irradiating laser beams. More intensive laser beam causes more severe ablation. Ablation of unit mass requires more than average incident energy if duty cycle of the laser pulses decreases. In addition, it is realized that the repetitive frequency rate of laser has minor effect on ablation as long as average beam intensity and duty cycle are fixed. For C/SiC material, introducing of some instabilities into laser beams would enhance the ablation process, which leads to low ablation heat.
参考文献

[1] 孙景超, 张永忠, 宫新勇, 等. 激光熔化沉积Ti60合金、TiCp/Ti60复合材料的高温拉伸持久寿命及断裂过程[J]. 中国激光, 2012, 39(1): 0103002.

    Sun Jingchao, Zhang Yongzhong, Gong Xinyong, et al.. High-temperature tensile rupture life and fracture procedure of laser direct deposited Ti60 Alloy and TiCp/Ti60 composites[J]. Chinese J Lasers, 2012, 39(1): 0103002.

[2] 朱凯,龙连春. 激光辐照层合板的数值模拟与试验对比[J]. 中国激光, 2012, 39(1): 0103004.

    Zhu Kai, Long Lianchun. Numerical simulation and experiment contrast about laminated plate under laser irradiation[J]. Chinese J Lasers, 2012, 39(1): 0103004.

[3] 汤文辉, 冉宪文. 强激光对靶材烧蚀效应的数值模拟研究[J]. 航天器环境工程, 2010, 27(1): 32-34.

    Tang Wenhui, Ran Xianwen. Numerical simulation of high intensity laser ablation of materials[J]. Spacecraft Environment Engineering, 2010, 27(1): 32-34.

[4] 张永强, 王贵兵. 两种纤维增强复合材料连续激光烧蚀阈值测量及吸收特性分析[J]. 强激光与粒子束, 2009, 21(2): 199-202.

    Zhang Yongqiang, Wang Guibing. Ablation threshold measurement and absorption characteristic analysis of two fiber reinforced composites irradiated by CW laser[J]. High Power Laser and Particle Beams, 2009, 21(2): 199-202.

[5] 陈林柱. 蜂窝夹层复合材料激光烧蚀实验研究[M]. 西安: 西北核技术研究所, 2010.

    Chen Linzhu. Experiment Research to Laser Ablation of Honeycomb Sandwich Composite[M]. Xi′an: Northwest Institute of Nuclear Technology, 2010.

[6] 王贵兵, 刘仓理. 凯芙拉环氧复合材料烧蚀阈值实验研究[J]. 激光技术, 2003, 27(5): 457-459.

    Wang Guibing, Liu Cangli. Experimental research of the ablation threshold of Kevlar/ epoxy[J]. Laser Technology, 2003, 27(5): 457-459.

[7] 彭国良, 王玉恒. C/C复合材料的氧化对激光防护的影响研究[J]. 激光与红外, 2013, 43(2): 148-151.

    Peng Guoliang, Wang Yuheng. Research to the effect of carbon-carbon composites oxidation on laser protection[J]. Laser & Infrared, 2013, 43(2): 148-151.

[8] 陈思员, 姜贵庆. 碳化硅材料被动氧化机理及转捩温度分析[J]. 宇航材料工艺, 2009, (3): 21-24.

    Chen Siyuan, Jiang Guiqing. Passive oxidation mechanism and transition temperature of silicon carbide[J]. Aerospace Materials & Technology, 2009, (3): 21-24.

[9] M Balat, G Flamant, G Male, et al.. Active to passive transition in the oxidation of silicon carbide at high temperature and low pressure in molecular and atomic oxygen[J]. Journal of Materials Science, 1992, 27(3): 697-703.

[10] J B Henderson. An Analytical and Experimental Study of the Pyrolysis of Composite Ablative Materials[D]. Oklahoma: Oklahoma State University, 1980.

[11] 武文明. C/SiC复合材料热辐射性能研究[D]. 西安: 西北工业大学, 2005.

    Wu Wenming. Investgation of the Thermal Radiation Properties of C/SiC Composites[D]. Xi′an: Northwestern Polytechnical University, 2005.

[12] 李宏. 2.5维C/SiC复合材料的热物理及力学性能[D]. 西安: 西北工业大学, 2007.

    Li Hong. Thermophysical and Mechanical Properties of 2.5D C/SiC Composites[D]. Xi′an:Northwestern Polytechnical University, 2007.

彭国良, 张相华, 王玉恒, 闫辉, 高银军, 郑艳丽. 激光参数对C/SiC复合材料烧蚀热的影响[J]. 中国激光, 2013, 40(11): 1103010. Peng Guoliang, Zhang Xianghua, Wang Yuheng, Yan Hui, Gao Yingjun, Zheng Yanli. Effect of Laser Parameters on C/SiC Composites Material Ablation Heat[J]. Chinese Journal of Lasers, 2013, 40(11): 1103010.

本文已被 1 篇论文引用
被引统计数据来源于中国光学期刊网
引用该论文: TXT   |   EndNote

相关论文

加载中...

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!