用于高侧开关的短路限流及保护电路

提出了一种用于高侧开关的短路限流及保护电路。电路采用二级保护的方式,当短路检测电压不为零且低于参考电压时,限制栅源电压，对电路限流;当短路检测电压高于参考电压时,则延时一段时间后关断功率管。芯片采用0.18 μm 100 V BCD工艺流片。测试结果表明,在先工作后短路和先短路后工作两种情况下,功率管均处于正常工作状态。电路工作电压范围为4~80 V,短路延时时间约200 μs,输出最大可持续电流可达80 A。

Abstract

A short circuit current limiting and protection circuit for high side switches was presented. The mode of secondary protection was adopted by the circuit. When the short circuit detection voltage was not zero and lower than the reference voltage, the grid source voltage was limited to suppress the current of the circuit. When the short circuit detection voltage was higher than the reference voltage, the power tube would be turned off after a time delay. The chip was fabricated in a 100 V 0.18 μm BCD process. The test results showed that the power transistor was in normal working state under the two conditions of working before short circuit and working after short circuit. The working voltage range of the circuit was 4~80 V, the short circuit delay time was about 200 μs, and the maximum sustainable output current could reach 80 A.

参考文献

[1] Infineon BTS50055_1TMA datasheet ［Z］. 2010.

[2] 张金鹏, 隋建鹏, 江进, 等. 智能MOSFET在汽车电子系统中的应用［J］. 吉林大学学报(信息科学版), 2018, 36(4): 392-397.

[3] 李振民, 刘事明, 张锐. IGBT驱动及短路保护电路研究［J］. 电测与仪表, 2002, 39(6): 48-50.

[4] 梁怀天, 方舟, 罗攀, 等. 一种高侧功率开关的输出短路保护电路［J］. 微电子学, 2021, 51(1): 10-15.

[5] WANG J, SHEN Z, BURGOS R, et al. Design of a high-bandwidth Rogowski current sensor for gate-drive short circuit protection of 1.7 kV SiC MOSFET power modules ［C］// IEEE 3rd WiPDA. Blacksburg, VA, USA. 2015: 104-107.

[6] 陈钢. 一种28 V/1.8 A智能功率开关的保护电路设计［D］. 成都: 电子科技大学, 2016.

[7] 辛金明, 李小宇. 一种短路保护电路: CN2764032 ［P］. 2004.

[8] 毕查德·拉扎维. 模拟CMOS集成电路设计［M］. 西安:西安交通大学出版社, 2003.

[9] 童诗白, 华成英. 模拟电子技术基础［M］. 第三版. 北京:高等教育出版社, 2001.

[10] 吴海富, 张建忠, 赵进, 等. SiC MOSFET短路检测与保护研究综述［J］. 电工技术学报, 2019, 34(21): 4519-4528.

[11] PASETTI G, SAPONARA S, TINFENA F, et al. An integrated smart driver for inductive load swith self-monitoring/diagnostic capability ［C］// SPEEDAM. Sorrento, Italy. 2012: 1007-1011.

[12] SAPONARA S, FANUCCI L, PASETTI G, et al. Fully integrated multi-channel inductive load driver for harsh automotive applications ［J］. Analog Integr Circ Signal Process, 2016, 88(3): 485-494.

李豪, 熊平, 杨世红, 王晓婧, 耿莉, 李丹. 用于高侧开关的短路限流及保护电路[J]. 微电子学, 2022, 52(4): 700. LI Hao, XIONG Ping, YANG Shihong, WANG XiaoJing, GENG Li, LI Dan. A Short Circuit Current Limiting and Protection Circuit for High Side Switches[J]. Microelectronics, 2022, 52(4): 700.

用于高侧开关的短路限流及保护电路

关于本站 Cookie 的使用提示

全站搜索

用于高侧开关的短路限流及保护电路

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索