光通信技术, 2023, 47 (3): 0079, 网络出版: 2024-01-28  

应用于注水井的靶式光纤布喇格光栅流量传感器

Target fiber Bragg grating flow sensor for water injection well
作者单位
1 西安石油大学 理学院,西安710065
2 中国石油测井有限责任公司 测井技术研究院,西安710005
3 西北大学 物理学院,西安710127
摘要
为了解决注水井下安装和维护传感器难度大和成本高的问题,设计和理论分析了一种基于杠杆-铰链结构的靶式光纤布喇格光栅(FBG)流量传感器,将传感器结构中的FBG1和FBG3分别粘贴在杠杆-铰链两端构成差动结构,使传感器具有低启动与大量程特性;通过温度补偿光栅FBG2实现了温度和流量的同时测量。对传感器的结构进行了仿真与优化,得出传感器的优化参数,并以此参数为基础进行流量测量、重复性、温度测量、温度补偿、稳定性等实验。实验结果表明,该传感器可以同时测量流体流量和温度,其温度灵敏度为17.94 pm/℃,流量分辨率为0.039 L/s。
Abstract
In order to solve the problems of difficulty and high cost in installing and maintaining sensors in water injection well, a target type fiber Bragg grating(FBG) flow sensor based on lever-hinge structure is designed and theoretically analyzed. FBG1 and FBG3 in the sensor structure are pasted on the two ends of lever-hinge respectively to form a differential structure, which makes the sensor have the characteristics of low start-up and large range. Temperature compensation grating FBG2 is used to measure the temperature and flow simultaneously. The structure of the sensor is simulated and optimized, and the optimization parameters of the sensor are obtained. Based on these parameters, flow measurement, repeatability, temperature measurement, temperature compensation and stability experiment are carried out. The experimental results show that the sensor can simultaneously measure the fluid flow and temperature, its temperature sensitivity is 17.94 pm/℃ and the flow resolution is 0.039 L/s.
参考文献

[1] SVALOV A M. Hydrodynamic researches of nonlinear filtrations in low-permeable reservoirs[J]. Neftyanoe khozyaystvo - Oil Industry, 2021(1): 32-37.

[2] KHAN M J, MUTHER T, AZIZ H, et al. Investigating the impact of injection-water salinity and well strategies on water mobility and oil production in an oil-wet reservoir[J]. Modeling Earth Systems and Environment, 2021, 7(1): 247-260.

[3] HRIBAR J, DONLAGIC D. Optical flow sensor based on the thermal time-of-flight measurement[J]. Optics Express, 2021, 29(6): 8846-8860.

[4] PERIKALA M, PATHI V V L, RAJAN L S, et al. Cantilever supported Fiber Bragg Grating flow sensor for space applications[J]. IEEE Sensors, 2021, 21(3): 2651-2657.

[5] SHEN W, YAN R J, XU L, et al. Application study on FBG sensor applied to hull structural health monitoring[J]. Optik, 2015, 126(17): 1499-1504.

[6] MARQUES R D, PRADO A, ANTUNES P, et al. Corrosion resistant FBG-based quasi-distributed sensor for crude oil tank dynamic temperature profile monitoring[J]. Sensors, 2015, 15(12): 30693-30703.

[7] CAI S S, LIU F, WANG R L, et al. Narrow bandwidth fiber-optic spectral combs for renewable hydrogen detection[J]. Science China Informa-tion Sciences, 2020, 63(12): 221-229.

[8] 赵煜,朱志成,牛美玲,等. 光纤传感技术在流量检测方面的应用研究[J]. 光通信技术,2019,43(5):5-8.

[9] 马跃辉,刘兴,王华,等. 基于磁致伸缩效应的FBG电流传感器[J]. 光通信技术,2022,46(3):18-21.

[10] 冯森林,王兆香,王谦,等. 一种用于同时测量温度和磁场强度的磁流体LPFG-FBG传感器[J]. 光通信技术,2023,47(2):28-33.

[11] LYU G H, CHE G H, LI J Q, et al. Design of novel FBG-based sensor of differential pressure with magnetic transfer[J]. Sensors, 2017, 17(2): 375-383.

[12] LV R Q, ZHENG H K, ZHAO Y, et al. An optical fiber sensor for simultaneous measurement of flow rate and temperature in the pipeline[J]. Optical Fiber Technology, 2018, 45: 313-318.

[13] ZHANG T X, GUO T, WANG R H, et al. A hot-wire flowmeter based on fiber extrinsic Fabry-Perot Interferometer with assistance of fiber Bragg grating[J]. Optics Communications, 2021, 497: 126952-1-126952-5.

[14] LIM J, YANG Q P, JONES B E, et al. DP flow sensor using optical fibre Bragg grating[J]. Sensors and Actuators. A: Physical, 2001, 92(1): 102-108.

[15] 李洪才,刘春桐,冯永保,等.一种内嵌喷嘴差压式FBG流量传感器[J]. 光电子·激光,2014,25(10):1886-1891.

[16] GUO W, WANG L, LIU C P. Prediction of gas-liquid two-phase flow rates through a vertical pipe based on thermal diffusion[J]. Industrial & Engineering Chemistry Research, 2021, 60(6): 2686-2697.

[17] LI Y, YAN G, ZHANG L, et al. Microfluidic flowmeter based on micro hot-wire sandwiched Fabry-Perot interferometer[J]. Optics Express, 2015, 23(7): 9483-9493.

[18] LIU Z Y, HTEIN L, CHENG L K, et al. Highly sensitive miniature fluidic flowmeter based on an FBG heated by Co2+-doped fiber[J]. Optics Express, 2017, 25(4): 4393-4402.

[19] ZHAO Q, ZHENG H K, LV R Q, et al. Novel integrated optical fiber sensor for temperature, pressure and flow measurement[J]. Sensors and Actuators A: Physical, 2018, 280: 68-75.

[20] LIU C, ZHANG Z, LI H, et al. Research on one-piece structure target flow sensing technology based on fiber Bragg grating[J]. Photonic Sensors, 2016, 6(4): 303-311.

[21] ZHAO Y, GU Y F, LV R Q, et al. A small probe-type flowmeter based on the differential fiber Bragg grating measurement method[J]. IEEE Tran-sactions on Instrumentation and Measurement, 2017, 66(3): 502-507.

[22] OOI B L, GILBERT J M, AZIIZ A R A. Analytical and finite-element study of optimal strain distribution in various beam shapes for energy harvesting applications[J]. Acta Mechanica Sinica,2016, 32(4): 670-683.

[23] JAMES S W, DOCKNEY M L, TATAM R P. Simultaneous independent temperature and strain measurement using in-fibre Bragg grating sensors[J]. Electronics Letters, 1996, 32(12): 1133-1134.

[24] 陈贵敏,贾建援,刘小院,等. 椭圆柔性杠杆-铰链的计算与分析[J]. 工程力学,2006,23(5):152-156.

[25] 向洋,孙世政,党晓圆,等. 基于光纤布喇格光栅的流量温度复合传感研究[J]. 电子测量与仪器学报,2021,35(14):15-22.

[26] 刘春桐,王鹏致,李洪才,等. 一种FBG靶式流量传感的结构设计及实验研究[J]. 光电子·激光,2015,26(3):529-534.

张栋宇, 白燕, 刘国权, 陈强, 乔学光. 应用于注水井的靶式光纤布喇格光栅流量传感器[J]. 光通信技术, 2023, 47(3): 0079. ZHANG Dongyu, BAI Yan, LIU Guoquan, CHEN Qiang, QIAO Xueguang. Target fiber Bragg grating flow sensor for water injection well[J]. Optical Communication Technology, 2023, 47(3): 0079.

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!