海水和矿物掺合料对硫铝酸盐水泥砂浆性能的影响

刘泽平; 王传林; 张宇轩; 张腾腾

硅酸盐通报, 2022, 41 (4): 1245, 网络出版: 2022-08-03

海水和矿物掺合料对硫铝酸盐水泥砂浆性能的影响

Effects of Sea Water and Mineral Admixture on Properties of Sulphoaluminate Cement Mortar

论文大纲

刘泽平 ^1,*王传林 ^1,2张宇轩 ¹张腾腾 ¹

作者单位

¹ 汕头大学土木与环境工程系, 汕头 515063

² 广东省结构安全与监测工程技术研究中心, 汕头 515063

硫铝酸盐水泥海水海砂粉煤灰硅灰水化产物 sulphoaluminate cement sea water sea sand fly ash silica fume hydration product

摘要

本文研究了不同拌和水以及海水拌和时粉煤灰和硅灰掺量对硫铝酸盐水泥(SAC)砂浆力学性能和表观孔隙率以及净浆凝结时间、化学收缩、孔溶液pH值和氯离子结合能力等的影响, 并通过XRD、SEM和EDS分析水泥水化产物和微观结构。结果表明, 海水能加快SAC早期水化并提高其早期强度, 但后期强度和淡水拌和时无明显差别。粉煤灰和硅灰均会延长SAC凝结时间, 对早期抗压强度不利, 而掺加质量分数为5.0%和7.5%的硅灰能提高SAC砂浆28 d抗压强度。硅灰掺量增加时会提高用水量和表观孔隙率, 降低流动性, 使水泥化学收缩增大, 降低净浆pH值且减少氯离子结合量; 粉煤灰能够提高砂浆流动性, 减少水泥化学收缩, 但掺量越大对SAC砂浆抗压强度和抗折强度越不利, 掺质量分数为10%的粉煤灰可小幅提高氯离子结合量且减小表观孔隙率。

Abstract

In this paper, the effects of sea water and mineral admixture on the mechanical properties and apparent porosity of sulphoaluminate cement (SAC) mortar, the properties such as setting time, chemical shrinkage, pH value of pore solution and chloride ion binding capacity of paste were studied. Furthermore, the hydration products and the microstructure of SAC were analyzed by XRD, SEM and EDS. The results show that sea water accelerates the early hydration of SAC and improves its early strength, while there is no significant difference in the long-term strength of cement mortar between sea water and fresh water. Both fly ash and silica fume prolong the setting time of SAC, which is disadvantageous to the early compressive strength. 28 d compressive strength of SAC mortar improves with the silica fume mass fraction of 5.0% and 7.5%. As the silica fume content increases, the water consumption, chemical shrinkage and apparent porosity of SAC increase. However, the fluidity, the pH value and the chloride ion binding amount of cement paste reduce with the increase of silica fume content. Meanwhile, Fly ash improves the fluidity of mortar and reduces the chemical shrinkage of cement paste. But the adverse effect on the compressive strength and flexural strength of SAC mortar is more obvious with the increase of fly ash content. When 10% (mass fraction) fly ash is added, the chloride ion binding amount increases and the apparent porosity reduces slightly.

参考文献

[1] BENDIXEN M, BEST J, HACKNEY C, et al. Time is running out for sand[J]. Nature, 2019, 571(7763): 29-31.

[2] 邢丽,薛瑞丰,曹喜.海砂海水混凝土性能研究[J].混凝土,2015(11):137-141.

[3] MILLER S A, HORVATH A, MONTEIRO P J M. Impacts of booming concrete production on water resources worldwide[J]. Nature Sustainability, 2018, 1(1): 69-76.

[4] 黄有强.海水对硫铝酸盐水泥混凝土性能的影响研究[D].武汉:武汉理工大学,2016.

[5] 王燕谋,苏慕珍,张量.硫铝酸盐水泥[M].北京:北京工业大学出版社,1999.

[6] 廖宜顺,刘楚明,康爽,等.海水环境下矿物掺合料对硫铝酸盐水泥的水化影响[J].硅酸盐通报,2017,36(4):1333-1338.

[7] 廖国胜,徐路,廖宜顺.硅灰对硫铝酸盐水泥水化行为的影响机理[J].建筑材料学报,2017,20(6):840-845.

[8] 简险峰,王栋民,黄天勇,等.普通硅酸盐水泥基矿物掺合料对硫铝酸盐水泥性能的影响[J].硅酸盐通报,2014,33(4):984-987.

[9] 李正学,戴绍斌,马保国,等.钢渣-粉煤灰-硅灰复合改性剂对硫铝酸盐水泥性能的影响[J].硅酸盐通报,2020,39(1):175-181.

[10] 金祖权,孙伟,李秋义,等.矿物掺合料对海水中氯离子的结合能力[J].腐蚀与防护,2009,30(12):869-873.

[11] 蒋卓,雷学文,廖宜顺,等.粉煤灰对硫铝酸盐水泥水化历程的影响[J].硅酸盐通报,2016,35(12):4088-4092+4103.

[12] 王小刚,史才军,何富强,等.氯离子结合及其对水泥基材料微观结构的影响[J].硅酸盐学报,2013,41(2):187-198.

[13] 肖忠明,郭俊萍.混合材对硫铝酸盐水泥抗折强度倒缩的抑制作用及机理[J].水泥,2017(3):10-13.

[14] 李响,阎培渝.粉煤灰掺量对水泥孔溶液碱度与微观结构的影响[J].建筑材料学报,2010,13(6):787-791+835.

[15] NIXON P J, PAGE C L, BOLLINGHAUS R, et al. The effect of a PFA with a high total alkali content on pore solution composition and alkali silica reaction[J]. Magazine of Concrete Research, 1986, 38(134): 30-35.

[16] 王中平,彭相,赵亚婷,等.海水对不同矿物组成的铝酸盐水泥水化的影响[J].硅酸盐学报,2020,48(8):1240-1248.

[17] 张金喜,金珊珊.水泥混凝土微观孔隙结构及其作用[M].北京:科学出版社,2014: 77-79.

[18] WANG C L, LIU Z P, ZHANG T T, et al. Influence of the concentration of seawater on the early hydration properties of calcium sulphoaluminate (CSA) cement: a preliminary study[J]. Buildings, 2021, 11(6): 243.

[19] 郑娟,李辉,徐名凤,等.海水对高贝利特硫铝酸盐水泥水化过程和力学性能的影响[J].硅酸盐通报,2021,40(9):2898-2904+2920.

刘泽平, 王传林, 张宇轩, 张腾腾. 海水和矿物掺合料对硫铝酸盐水泥砂浆性能的影响[J]. 硅酸盐通报, 2022, 41(4): 1245. LIU Zeping, WANG Chuanlin, ZHANG Yuxuan, ZHANG Tengteng. Effects of Sea Water and Mineral Admixture on Properties of Sulphoaluminate Cement Mortar[J]. Bulletin of the Chinese Ceramic Society, 2022, 41(4): 1245.

海水和矿物掺合料对硫铝酸盐水泥砂浆性能的影响

关于本站 Cookie 的使用提示

全站搜索

海水和矿物掺合料对硫铝酸盐水泥砂浆性能的影响

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索