积分光谱与近红外光谱分析精度关系的研究

耿响; 陈斌; 朱文静; 颜辉

doi:doi:10.3788/aos20092912.3551

光学学报, 2009, 29 (12): 3551, 网络出版: 2009-12-23

积分光谱与近红外光谱分析精度关系的研究

Study on the Relation Between Integration Spectrum and Accuracy of Near Infrared Spectroscopic Analysis

论文大纲

耿响 ^*陈斌朱文静颜辉

作者单位

江苏大学食品与生物工程学院,江苏镇江 212013

光谱学近红外光谱分辨率积分光谱积分区间脂肪 spectroscopy near-infrared spectroscopy resolution integral spectrum integral interval fat

摘要

以MPA型傅里叶近红外光谱仪和WQF-400N型傅里叶近红外光谱仪上检测的奶粉光谱为原始光谱,利用积分法选择不同的积分区间对原始光谱进行积分,模拟不同分辨率下的光谱。采用相同的预处理方法〖CD2〗Savitzky-Golay平滑和一阶微分,利用偏最小二乘(PLS)回归对奶粉中的脂肪含量建立模型。分别比较两台仪器所建模型的相关系数(R),预测均方差(fRMSEP),平均相对误差(E)三个预测参数,得到两台仪器分别在分辨率为16 cm-1和64 cm-1时建模效果最好。研究结果表明,利用积分光谱,能起到压缩数据,提高模型预测精度的作用;同时说明对于具体样品的特定指标要选择合适的分辨率,在减少工作量的同时获得最佳的定量分析结果,而单纯的追求高分辨率是没有意义的。

Abstract

The raw spectra of milk powder were detected by means of two Fourier near-infrared spectrometers MPA type and WQF-400N type. Primitive spectra were integrated in different integral intervals to simulate spectra with different resolutions. After being pre-treated with the same methods (Savitzky-Golay smoothing and the first derivative),models for fat content in milk powder were established through partial least square regression (PLS). Comparisons on correlation coefficient R,root mean square error of prediction fRMSEP and mean bias E between the models reveal that MPA type and WQF-400N type spectrometers have the best models at the resolutions of 16 cm-1 and 64 cm-1 respectively. These results show that integral spectrum could compress data and enhance the model′s prediction accuracy,and that an adequate resolution should be selected for special characters of different samples. Both of them ensure the best quantitative analytical result while reducing the work load. It is of no significance to simply pursue higher and higher resolution.

参考文献

[1] 常敏,褚鹏蛟,徐可欣. 近红外漫反射光谱无损检测乳粉蛋白质的研究[J]. 光谱学与光谱分析,2007,27(1):43-45

Chang Min,Chu Pengjiao,Xu Kexin. Study on noninvasive detection using NIR diffuse reflectance spectrum for monitoring protein content in milk powder[J]. Spectroscopy and Spectral Analysis,2007,27(1):43-45

[2] 赵杰文,张海东,刘木华. 简化苹果糖度预测模型的近红外光谱预处理方法[J]. 光学学报,2006,26(1):136-140

Zhao Jiewen,Zhang Haidong,Liu Muhua. Preprocessing methods of near-inf rared spectra for simplifying prediction model of sugar content of apples[J]. Acta Optica Sinica,2006 ,26(1):136-140

[3] . M. Amigo,J. Cruz,M. Bautista et al.. Study of pharmaceutical samples by NIR chemical-image and multivariate analysis[J]. Trac-Trend. Anal. Chem., 2008, 27(8): 696-713.

[4] 韩东海,王加华. 水果内部品质近红外光谱无损检测研究进展[J]. 中国激光,2008,35(8):1123-1131

Han Donghai,Wang Jiahua. Review of non-destructive measurement of fruit quality by means of near infrared spectroscopy[J]. Chinese J. Lasers,2008,35(8):1123-1131

[5] 段焰青,杨涛,孔祥勇等. 样品粒度和光谱分辨率对烟草烟碱NIR预测模型的影响[J]. 云南大学学报(自然科学版),2006,28(4):340-344

Duan Yanqing,Yang Tao,Kong Xiangyong et al.. Effects of sample granularity and spectral resolution on tobacco nicotine NIR predoctive model[J]. J. Yunnan University (Natrual Sciences Edition),2006,28(4):340-344

[6] 王一兵,王红宇,翟宏菊等. 近红外光谱分辨率对定量分析的影响[J].分析化学研究简报,2006,34(5):699-701

Wang Yibing,Wang Hongyu,Zhai Hongju et al.. Influence of near infrared spectral resolution on the quantitative analysis[J]. Chinese J. Anal. Chem.,2006,34(5):699-701

[7] 谢丽娟,刘东红,张宇环等. 分辨率对近红外光谱和定量分析的影响研究[J]. 光谱学与光谱分析,2007,27(8):1489-1492

Xie Lijuan,Liu Donghong,Zhan Yuhuan et al.. Study on the influence of resolution on near infrared spectra and quantitative analysis[J]. Spectroscopy and Spectral Analysis,2007,27(8):1489-1492

[8] 中华人民共和国国家技术监督局,GB/T 5413.3-5413.32,1997婴幼儿配方食品和乳粉通用检验方法[S]. 中国标准出版社,1997. 1-9

The State Bureau of Quality and Technical Supervision,GB/T5413.1-5413.32,The Universal Method of Infant Formulas and Milk Powder[S]. Chinese Standard Press,1997. 1-9

[9] 王云,徐可欣,常敏. 近红外光谱技术检测牛奶中脂肪及蛋白质含量校正模型的建立[J]. 光学仪器,2006,28(3):3-7

Wang Yun,Xu Kexin,Chang Min. Study on multi-band NIR spectroscopy for the determ ina tion of fat and protein conten ts in milk[J]. Optical Instruments,2006,28(3):3-7

[10] 刘强,罗长兵,陈绍江等. 近红外光谱分析青贮玉米NDF中判别异常光谱的研究[J]. 光谱学与光谱分析,2007,27(8):1514-1518

Liu Qiang,Luo Changbing,Chen Shaojiang et al.. An outlier diagnosis on near infrared spectroscopy analysis of NDF content in corn silage feeds[J]. Spectroscopy and Spectral Analysis,2007,27(8):1514-1518

[11] . Ververidis,C. Kotropoulos. Gaussian mixture modeling by exploiting the mahalanobis distance[J]. IEEE T. Signal Process., 2008, 56(7): 2797-2811.

[12] 张鑫,郭佳,倪力军. 基于红外与近红外光谱的烟叶部位识别[J]. 光谱学与光谱分析,2007,27(12):2437-2440

Zhang Xin,Guo Jia,Ni Lijun . Recognition of plant parts of tobaccos based on infrared and near infrared spectra [J]. Spectroscopy and Spectral Analysis,2007,27(12):2437-2440

[13] 陈全胜,赵杰文,张海东等. 基于支持向量机的近红外光谱鉴别茶叶的真伪[J]. 光学学报,2006,26(6):933-937

Chen Quansheng,Zhao Jiewen,Zhang Haidong et al.. Indentification of authenticity of tea with near infrared spectroscopy based on support vector machine[J] . Acta Optica Sinica,2006,26(6):933-937

[14] 严衍禄,赵龙莲,韩东海等. 近红外光谱分析基础与应用[M]. 北京:中国轻工业出版社,2005. 121-137

Yan Yanlu,Zhao Longlian,Han Donghai et al.. The Basis and Application of the Analysis Technique for Near Infrared Spectra[M]. Beijing :Chinese Light Industry Press,2005. 121-137

[15] 吴瑾光. 近代傅里叶变换红外光谱技术及应用[M]. 北京:科学技术文献出版社,1994.129-130

Wu Jinguang. The Technology And Application of Modern Fourier Transform Infrared Spectroscopy [M]. Beijing:Scientific and Technical Document Press,1994. 129-130

[16] A. D. Burns,W. E. Ciurzak. Handbook of Near Infrared Analysis[M]. New York:CRC Press,1992. 189-203

耿响, 陈斌, 朱文静, 颜辉. 积分光谱与近红外光谱分析精度关系的研究[J]. 光学学报, 2009, 29(12): 3551. Geng Xiang, Chen Bin, Zhu Wenjing, Yan Hui. Study on the Relation Between Integration Spectrum and Accuracy of Near Infrared Spectroscopic Analysis[J]. Acta Optica Sinica, 2009, 29(12): 3551.

积分光谱与近红外光谱分析精度关系的研究

关于本站 Cookie 的使用提示

全站搜索

积分光谱与近红外光谱分析精度关系的研究

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索