中国激光, 2004, 31 (8): 959, 网络出版: 2006-06-12   

Sb∶SnO2/SiO2纳米复合薄膜的光学及气敏特性

Optical and Gas-Sensing Properties of Sb-Doped SnO2/SiO2 Nano-Composite Thin Films
作者单位
1 上海理工大学理学院光电功能薄膜实验室, 上海 200093
2 中国科学院上海光学精密机械研究所,上海 201800
摘要
采用溶胶-凝胶(sol-gel)工艺制备了Sb∶SnO2/SiO2复合膜。通过原子力显微镜(AFM)观察了薄膜样品的表面形貌,利用紫外-可见光谱,p-偏振光反射比角谱研究了复合薄膜的光学特性。结果表明,薄膜中的晶粒具有纳米尺寸(~35 nm)的大小,比表面积大,孔隙率高;薄膜的透光率高,可见光波段近95%;其光学禁带宽度约3.67 eV。因此Sb∶SnO2/SiO2纳米复合膜可作为气敏薄膜的理想选择。通过对三种不同的气体C3H8,C2H5OH及NH3气敏特性的测试表明,Sb掺杂大大提高了SnO2薄膜对C2H5OH的灵敏度,纳米Sb∶SnO2/SiO2复合膜的气敏灵敏度高于纯SnO2薄膜及Sb掺杂的SnO2薄膜。
Abstract
Sb-doped SnO2/SiO2 nano-composite thin films are prepared by sol-gel method. The surface topograph of the thin films is observed by atomic force microscopy (AFM). The optical properties of the thin films are studied by ultraviolet-visible spectra and p-polarized light reflectance angular spectrum. The results show that the crystalline grain size is about 35 nm, the specific surface area is large, and the duty porosity is high;the optical transmissivity is high, near 95% in visible spectrum range,and the optical band gap is about 3.67 eV. So Sb-doped SnO2/SiO2 nano-composition thin films is ideal candidate for optical gas-sensing. Further more, the gas-sensing test is made to three kinds of gas C3H8, C2H5OH and NH3, the results indicate, the doping of Sb to SnO2 films greatly improves the gas sensitivity to C2H5OH, and the gas sensitivity of Sb∶SnO2/SiO2 nano-composite thin films is higher than that of Sb∶SnO2 thin films.
参考文献

[1] J. W. Gardner, H. V. Shurner, P. Corcoran. Integrated tin oxide odour sensors[J]. Sensors and Actuators, 1991, B4:117~121

[2] . G. Ansari, S. W. Gosavi, S. A. Gangal et al.. Characterization of SnO2-based H2 gas sensors fabricated by different deposition technigues[J]. J. Mater. Sci., 1997, 8: 23-27.

[3] Liu Xiaolin, Liang Peihui, Zhang Weiqing et al.. Optical properties of the Sol-Gel derived SnO2 films by ammonia treatment[J]. Acta Optica Sinica, 1999, 19(4):524~527
刘晓林,梁培辉,张伟清 等. 氨处理溶胶-凝胶SnO2薄膜的光学性质[J]. 光学学报, 1999, 19(4):524~527

[4] . Preparation and development of nano-particles[J]. Chemistry, 1996, 3: 1-6.

[5] M. de la L. Olvera, R. Asomoza. SnO2 and SnO2∶Pt thin films used as gas sensors[J]. Sensors and Actuators, 1997, B45:49~53

[6] . Licciulli, S. Mazzarelli. Os and Pd modified tin oxide films for sensors by the sol-gel process[J]. J. Sol-Gel Sci. and Technol., 2001, 21: 195-201.

[7] . D. Senguttuvan, L. K. Malhotra. Sol gel deposition of pure and antimony doped tin dioxide thin films by non alkoxide precursors[J]. Thin Solid Films, 1996, 289: 22-28.

[8] Li Fushan, Zhan Hongbing, Chen Wenzhe. Spectrum characterization of ZnPcS4 in silica Sol-Gel material[J]. Acta Optica Sinica, 2003, 23(1):109~111
李福山,詹红兵,陈文哲. 酞菁锌掺杂二氧化硅凝胶基质的光谱学特征[J]. 光学学报, 2003, 23(1):109~111

[9] J. Lin, M. Heurich, E. Obemeier. Manufacture and examination of various spin-on glass films with respect to their humidity-sensitive properties[J]. Sensors and Actuators, 1993, B13-14:104~109

[10] . T. Gu, P. H. Liang, X. L. Liu et al.. Novel sensitive scheme of determining the optical parameters of the thin films by p-polarized reflectance[J]. Measurement Sci. & Technol., 2000, 11(4): 56-61.

[11] . A. Fardad, E. M. Yeatman, E. J. Dawnay et al.. Effects of H2O on structure of acid-catalysed SiO2 sol-gel films[J]. J. Non-Crystalline Solids, 1995, 183: 260-267.

[12] . S. Park, J. D. Mackenzie. Sol-gel-derived tin oxide thin films[J]. Thin Solid Films, 1995, 258: 268-273.

[13] . D. Senguttuvan, L. K. Malhotra. Sol gel deposition of pure and antimony doped tin dioxide thin films by non alkoxide precursors[J]. Thin Solid Films, 1996, 289: 22-28.

[14] . S. Park, J. D. Mackenzie. Sol-gel-derived tin oxide thin films[J]. Thin Solid Films, 1995, 258: 268-273.

[15] . Chestnoy, T. D. Harris, R. Hull et al.. Luminescence and photophysics of CdS semiconductor clusters: the nature of the emitting electronic state[J]. J. Phys. Chem., 1986, 90: 3393-3399.

[16] Gu Zhengtian, Liang Peihui, Liu Xiaolin et al.. Optimization of optical parameters of the film sensor based on p-polarized reflectance[J]. Acta Optica Sinica, 1999, 19(11):1556~1562
顾铮天,梁培辉,刘晓林 等. 基于p-偏振光双面反射的薄膜传感器光学参数的优化[J]. 光学学报, 1999, 19(11):1556~1562

顾铮天, 梁培辉, 张伟清. Sb∶SnO2/SiO2纳米复合薄膜的光学及气敏特性[J]. 中国激光, 2004, 31(8): 959. 顾铮天, 梁培辉, 张伟清. Optical and Gas-Sensing Properties of Sb-Doped SnO2/SiO2 Nano-Composite Thin Films[J]. Chinese Journal of Lasers, 2004, 31(8): 959.

本文已被 1 篇论文引用
被引统计数据来源于中国光学期刊网
引用该论文: TXT   |   EndNote

相关论文

加载中...

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!